Heat & Glo LifeStyle CFL-30LP-B manual Heat & Glo CFL-18/24/30-B, ST-CFL-24 526-900 Rev. F 7/05

Page 16

B.Minimum inlet gas supply pressure for purposes of input adjustment, shall be 7.0 inches w.c. (1.75kPa) for natural gas and 11.0 inches w.c. (2.75kPa) for pro- pane (LP gas). Maximum inlet gas supply pressure shall be 14.0 in. w.c. (3.5kPa) for both natural gas and propane (LP gas). Manifold (outlet) pressure should be 3.5 inches w.c. (.87kPa) for natural gas and 10.0 inches w.c. (2.5kPa) for LP gas.

C.The appliance and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of the system at test pres- sures in excess of 1/2 psig (3.5kPa).

D.This appliance must be isolated from the gas sup- ply piping system by closing its individual manual shut off valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig (3.5kPa).

E. NOTE: THE GAS SUPPLY LINE SHOULD BE

PURGED OF ANY TRAPPED AIR PRIOR TO THE FIRST FIRING OF THE UNIT.

F.CAUTION: During the initial purging and sub- sequent lightings, NEVER allow the gas control valve knob to remain depressed in the "PILOT" po- sition without pushing the red ignitor button at least once every second.

G.A damper stop clamp with set screw is provided to prevent full closure of the fireplace damper blade. At- tach the clamp to the edge of the damper blade with pliers or wrenches. If the damper stop supplied does not fit the application, use a permanent means that will keep the damper open to a MINIMUM of 51 square inches (328cm2). See Figure 5.

WARNING: OPEN THE CHIMNEY DAMPER TO ITS FULLY OPEN POSITION WHEN BURNING THIS GAS LOG SET.

WARNING: LOGS MUST NEVER BE BURNED WITH- OUT THE FLUE DAMPER IN THE FULL OPEN POSI- TION. FAILURE TO DO SO IS DANGEROUS TO YOUR HEALTH AND VOIDS ALL WARRANTIES.

H. NOTE: The Commonwealthof Massachusetts re- quires that the chimney flue damper, when used with gas logs, shall be welded open or completely removed.

I. Your appliance control system is a millivolt type. It consists of a pilot burner, a gas control valve/regulator, a thermopile, a piezo ignitor, and an ON/OFF rocker switch. See Figure 6 for control system wiring diagram.

J. NOTE: An Optional Remote Control Kit and Wall Switch Kit , for turning the burner ON/OFF are avail- able. Detailed installation instructions are found in each kit.

K. Test fire the unit after referring to the SAFETY IN- FORMATION and LIGHTING INSTRUCTIONS found in Section 3 in this manual, or on the label plate as- sembly found on the gas-burner.

L. After the gas line installation is complete, all con- nections must be tightened and checked for leaks with

acommercially-available, non-corrosive leak check solution. Be sure to rinse off all leak check solution following testing. Refer to Section 3, OPERATING GUIDELINES and MAINTENANCE INSTRUCTIONS.

M. Once the gas-burner is test fired and gas supply lines are purged, assemble the grate(s) and logs. Be certain to follow the Log Placement Instructions shipped with your unit. Remember to keep the Log Instructions along with this manual for future use.

Figure 5

Figure 6

16

Heat & Glo • CFL-18/24/30-B, ST-CFL-24 • 526-900 Rev. F • 7/05

Page 15 Page 17
Image 16
Page 15 Page 17
Contents Installationand Operation Instructions Table of Contents CFL-18-B Service Parts List / Liste des pièces de rechange CFL-18-B CFL-24-B Service Parts List / Liste des pièces de rechange CFL-24-B CFL-30-B Service Parts List / Liste des pièces de rechange CFL-30-B ST-CFL-24 Service Parts List / Liste des pièces de rechange ST-CFL-24Model CFL-18-B Model CFL-24-B Model CFL-30-B Model ST-CFL-24 Assembly IntroductionHeat & Glo CFL-18/24/30-B, ST-CFL-24 526-900 Rev. F 7/05 Operating Guidelines and Maintenance Instructions LPG Propane InformationSafety Information For Your Safety Read Before LightingLighting Instructions To Turn OFF GAS ApplianceHigh Elevation Installation Limited Lifetime Warranty Heat & GLO GAS Appliance Products

CFL-24LP-B, CFL-30LP-B, CFL-18LP-B, ST-CFL-24LP specifications

Heat & Glo has established itself as a leader in the fireplace and heating solutions industry, and its LifeStyle series further solidifies this reputation. Within this innovative range, models such as the ST-CFL-24LP, CFL-18LP-B, CFL-24LP-B, and CFL-30LP-B stand out for their aesthetic appeal, efficient heating capabilities, and advanced technology.

One of the main features of these models is their contemporary design. Each unit is crafted with a sleek finish, making them an ideal addition to modern living spaces. The large fire viewing area provides an enhanced visual experience, allowing users to enjoy the mesmerizing flames from multiple angles. The clean, linear lines and minimalist framing options enable these fireplaces to seamlessly integrate into various interior designs.

Efficiency and performance are at the forefront of the LifeStyle series. Each model is equipped with a powerful heating system that employs innovative technology to provide maximum heat output while optimizing energy use. This ensures that not only will the space be heated effectively, but it will also remain cost-efficient, making it a great choice for environmentally conscious consumers.

The LifeStyle ST-CFL-24LP and its counterparts feature advanced electronic ignition systems, enhancing reliability while simplifying operation. With the easy-to-use remote control, users can adjust the flame height, heat settings, and even set timers, providing convenience and customized comfort at the touch of a button.

Moreover, these models incorporate ventless technology that allows for versatile installation options. This feature means there is no need for extensive venting, making it easier for homeowners to find the perfect spot for their fireplace without the constraints of traditional models. Whether placed in a living room, bedroom, or even outdoors, the LifeStyle series offers flexibility while ensuring safe operation.

Safety is also a critical consideration with the LifeStyle fireplaces. Each unit comes with built-in safety features, including automatic shut-off systems and flame sensors, ensuring peace of mind while the fireplace is in use.

In summary, the Heat & Glo LifeStyle ST-CFL-24LP, CFL-18LP-B, CFL-24LP-B, and CFL-30LP-B models are designed for those seeking a combination of aesthetics, efficiency, and advanced technology. With their contemporary styling, efficient heating capabilities, and user-friendly features, these models stand out as premium choices for any modern home setting.
Top Page Image Contents