Chamberlain 4000UK, 5000UK Start by Reading These Important Safety Rules, Contents, Door Types

Page 2

START BY READING THESE IMPORTANT SAFETY RULES

These safety alert symbols mean Caution – a personal safety or property damage instruction. Read these instructions carefully.

This garage door opener is designed and tested to offer reasonable safe service provided it is installed and operated in strict accordance with the following safety rules.

Failure to comply with the following instructions may result in serious personal injury or property damage.

Caution: If your garage has no service entrance door, Model 1702EML Outside Quick Release must be installed. This accessory allows manual operation of the garage door from outside in case of power failure.

1-GB

Keep garage door balanced. Sticking or binding doors must be repaired. Garage doors, door springs, cables, pulleys, brackets and their hardware are under extreme tension and can cause serious personal injury. Do not attempt to loose, move or adjust them. Call for garage door service.

Do not wear rings, watches or loose clothing while installing or servicing a garage door opener.

To avoid serious personal injury from entanglement, remove all ropes connected to the garage door before installing the door opener.

Installation and wiring must be in compliance with your local building and electrical codes. Connect the power supply cord only to properly earthed mains.

Lightweight doors of fiberglass, aluminum or steel must be substantially reinforced to avoid door damage. (See page 4.) The best solution is to check with your garage door manufacturer for an opener installation reinforcement kit.

The safety reverse system test is very important. Your garage door MUST reverse on contact with a 50mm obstacle placed on the floor. Failure to properly adjust the opener may result in serious personal injury from a closing garage door. Repeat the test once a month and make any needed adjustments.

This unit should not be installed in a damp or wet space.

Door must not extend over public byway during operation.

The force, as measured on the closing edge of the door, should not exceed 150 N (15kg). If the closing force is adjusted to more than 150 N, the Protector System must be installed. Do not use the force adjustments to compensate for a binding or sticking garage door. Excessive force will interfere with the proper operation of the Safety Reverse System or damage the garage door.

Fasten the caution label adjacent to the lighted door control button as a reminder of safe operating procedures.

Disengage all existing garage door locks to avoid damage to garage door.

Install the lighted door control button (or any additional push buttons) in a location where the garage door is visible, but out of the reach of children. Do not allow children to operate push button(s) or remote control(s). Serious personal injury from a closing garage door may result from misuse of the opener.

Activate opener only when the door is in full view, free of obstructions and opener is properly adjusted. No one should enter or leave the garage while the door is in motion. Do not allow children to play near the door.

Use manual release only to disengage the trolley and, if possible, only when the door is closed. Do not use the red handle to pull the door open or closed.

Disconnect electric power to the garage door opener before making repairs or removing covers.

This product is provided with a power supply cord of special design which, if damaged, must be replaced by a power supply cord of the same type; such a power supply cord may be obtained from your local Chamberlain distributor and must be fitted by a specialist.

 

CONTENTS

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

ASSEMBLY: Page 2 – Illustrations 5 –

10

 

 

OPERATION OF YOUR OPENER: Page 5

 

SAFETY RULES: Page 1

 

 

 

 

 

 

INSTALLATION:

 

 

 

 

 

 

 

 

 

 

 

 

CARE OF YOUR OPENER: Page 5

 

DOOR TYPES: Page 1 – Illustration

 

 

 

Pages 3-4 – Illustrations

 

11

–

20

 

 

 

 

 

PROBLEMS: Page 6

 

 

 

 

 

 

 

 

 

1

 

 

 

 

 

 

 

 

 

 

 

 

TOOLS REQUIRED: Illustration

 

 

 

 

 

 

 

PROGRAMMING THE CODE:

 

 

 

 

 

 

 

MAINTENANCE OF YOUR OPENER: Page 7

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

2

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Page 4 – Illustration

21

 

 

 

 

 

 

 

 

 

 

ACCESSORIES: Page 7 – Illustration

 

 

 

 

 

 

HARDWARE PROVIDED:

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

26

 

Page 1 – Illustration

3

 

 

 

 

 

 

 

 

ADJUSTMENT:

 

 

 

 

 

 

 

 

 

 

 

 

SPECIFICATIONS: Page 7

 

BEFORE YOU BEGIN: Page 2

 

 

 

 

 

 

Pages 4-5 – Illustrations

 

22

–

24

 

 

 

 

 

RAIL ASSEMBLY & INSTALLATION

 

 

 

 

 

 

 

 

 

 

 

INSTALL THE PROTECTOR SYSTEMTM

 

 

 

 

 

 

 

 

 

 

 

 

COMPLETED INSTALLATION:

 

 

 

 

 

 

 

 

PARTS LIST: Illustration

27

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Page 2 – Illustration

4

 

 

 

 

 

 

 

 

(Optional): Page 5 – Illustration

 

25

 

 

 

 

 

OPENER PARTS LIST: Illustration

28

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

DOOR TYPES –

1

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

A. One-Piece Door with Horizontal Track Only

 

 

 

 

 

D. Double-wing door – Special door arm required. See your dealer.

 

B. One-Piece Door with Horizontal and Vertical Track – Special door arm

 

E. Canopy door – Special door arm (F, The Chamberlain Arm™)

 

 

 

(F, The Chamberlain Arm™) required. See your dealer.

 

 

 

required. See your dealer.

 

 

 

 

 

 

 

 

 

 

C. Sectional Door with Curved Track – See

20

B – connect door arm.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

HARDWARE PROVIDED –

 

3

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Assembly Hardware:

 

 

 

 

 

 

 

 

Installation Hardware:

 

 

 

 

 

 

 

 

 

 

 

 

 

 

(1)

Washered Screws (2)

(7) Lock Nuts (12)

 

(12)

Carriage Bolts (2)

(17)

Rope

(22)

Nuts (9)

 

 

 

(2)

Hex Screws (2)

 

 

 

(8) Flat Washers (2)

 

(13)

Wood Screws (4)

(18)

Handle

(23)

Ring Fasteners (3)

 

 

 

(3)

Nuts (2)

 

 

 

(9) Hex Screws (2)

 

(14)

Screws (2)

(19)

Insulated Staples

(24)

Rail Grease

 

 

 

(4)

Lock Washers (2)

(10) Trolley Threaded Shaft (1)

 

(15)

Clevis Pins (2)

(20)

Anchors (2)

(25)

8mm Anchors (4)

 

 

 

(5)

Master Links (2)

 

 

 

(11) Clevis Pin (1)

 

(16)

Hex Screws (5)

(21)

Lock Washers (8)

(26)

Sheet Metal

 

 

 

(6)

Carriage Bolts (12)

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Screws (2)

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

114A2062H

Page 1 Page 3
Image 2
Page 1 Page 3
Contents Instructions Garage Door Operator Models Door Types Start by Reading These Important Safety RulesContents Hardware ProvidedInstall the Cable Pulley Bracket Completed InstallationAssembly Assemble the T-RAIL Install the TrolleyConnect Electric Power InstallationInstall the Header Bracket Position the Header BracketFasten Door Bracket Install the Light and LensAdjustment Limit Adjustment Connect Door ARM to TrolleyOperation of Your Opener Force AdjustmentTest the Safety Reverse System Care of Your OpenerUnit must be earthed Having a PROBLEM?Repeat safety reverse test after adjustment is complete Replacement Parts Maintenance of Your OpenerAccessories SpecificationsIllustrations Garage Door Operator Models 114A2063E 10mm, 8mm 5mm, 4mm 114A2063E 114A2063E 114A2063E 114A2063E 13mm 5cm 114A2063E RED 114A2063E 114A2063E 1EML34EML/41EML 41A2828 41A4251-3A41A3475-1 41A4208

5000UK, 4000UK specifications

The Chamberlain 4000UK and 5000UK are advanced garage door openers designed to enhance convenience, security, and efficiency for homeowners. With their impressive range of features and cutting-edge technologies, these models stand out in the market for their performance and reliability.

One of the key features of the Chamberlain 4000UK is its powerful motor, which provides smooth and quiet operation for sectional and up-and-over garage doors. The motor is engineered to deliver exceptional lifting capacity, making it suitable for various door sizes and weights. This ensures that homeowners can enjoy seamless access without the noise commonly associated with traditional garage door openers.

The 5000UK takes the power of the 4000UK to the next level, offering an even higher lifting capacity to accommodate larger and heavier garage doors. This makes it an ideal choice for those with heavyweight doors, giving users peace of mind in terms of performance and durability.

Both models incorporate intelligent technology that allows for remote control access. This includes compatibility with smartphones through the MyQ technology. Homeowners can control their garage door from anywhere, receive real-time notifications about the door's status, and even schedule opening and closing times. This level of connectivity adds a layer of convenience and enhances overall security.

Security is a paramount concern for all homeowners, and Chamberlain has addressed this with their patented PosiLock security system. This feature ensures that the garage door remains securely closed, preventing unauthorized access. The openers also come equipped with rolling code technology, which changes the access code each time the remote is used. This significantly reduces the risk of hacking and unauthorized entry.

Another characteristic that makes the Chamberlain 4000UK and 5000UK models stand out is their safety features. Both openers are designed with the Safe-T-Beam system, which uses invisible light beams to detect obstacles in the door's path. If something obstructs the door while closing, it automatically reverses, preventing accidents and injuries.

Installation is straightforward with both models, thanks to their user-friendly design and comprehensive manuals. Whether homeowners choose to install the units themselves or hire a professional, the process is efficient and hassle-free. Additionally, these openers are energy-efficient, combining performance with eco-friendliness.

In summary, the Chamberlain 4000UK and 5000UK garage door openers are powerful, secure, and intelligent solutions for modern homes. With features like smartphone compatibility, advanced security systems, and safety mechanisms, these models redefine convenience and safety in garage access. Homeowners can rest easy knowing they have a robust and reliable device managing their garage needs.
Top Page Image Contents