Miele G600, G800 manual Door Hinge Removal

Page 69

G600 & G800 Electronic Dishwashers

Technical Information

5.13Door Hinge - Removal

Refer to Figure 5-16.

1.Remove the Side Panel (5.3).

2.Remove the Outer Door Panel (5.10).

3.Remove the Tensioning Spring (5.4).

Figure 5-16: Hinge Removal

Warning!

Ensure the Door is held in position; and supported while opening it.

4.Open the Door. Remove the Raised Screws (Item 1).

5.Close the Door. Remove the Screw (Item 2).

6.Remove the Hinge Bolt Retainer (Item 3).

7.Remove the Hinge Bolt (Item 4).

8.Remove the Hinge.

Service Tip

When reassembling, lightly coat all moving parts with acid-free grease

69

Image 69

Contents G600 & G800 Electronic Dishwashers Technical InformationG600 & G800 Electronic Dishwashers Table of Contents Service and Maintenance……………………………………………………..57 G600 & G800 Electronic Dishwashers Table of ContentsG600 & G800 Electronic Dishwashers Table of Contents Operating Hours G600 &G800 Electronic Dishwashers List of Figures G600 &G800 Electronic Dishwashers List of Figures G600 &G800 Electronic Dishwashers List of Tables Construction and Design 2Appliance Overview Typical Fully Integrated Vi Model Unit Overview Typical Fully Integrated ModelControls Overview NovotronicTouchtronic Incognito 3Pre-Finished Dishwasher Types of DishwashersTechnical Data Dishwasher Width Fullsize / SlimlineDishwasher Height 600 / 800 Series Summary of Dimensions Electrical InformationG600 Series G800 Series Plumbing Connection Hard Wire Electrical ConnectionIntake Connection Drain ConnectionETL Certification -OR Data Tag9Component Overview Novotronic & Touchtronic Series Layout of Components Novotronic and Touchtronic Series10Component Overview Incognito Vi Series Incognito SeriesInstallation Door Handle and Door Lock Novotronic and Touchtronic Series Child Safety LockClosing the Dishwasher Door HorizontalWater Softener Salt Water SoftenerIf the Water Softener is needed If the Water Softener is not neededGeneral Operation Novotronic Series General Operation Touchtronic SeriesGeneral Operation Incognito Series Fan Assembly Units equipped with Turbothermic Fan Cabinet ConstructionPTC Release Element Units equipped with Turbothermic Fan Construction Combination DispenserDispensing Wash Cavity Heating Element HeatersFlow Through Heater Electrical Data 120VAC Flow Through Heater4Heater Circuit Heater Circuit OperationTemperature Protection Static DryingPulsed Heating Operation Filter Assembly Spray ArmsSpray Arms Rotation Data Water Intake Technical Data Flow Restrictor DataWater Inlet Mixer Data 6WaterProof System Connection WaterProof System WPSTechnical Information 7Water Intake Circuit Flowmeter Operation 8Flowmeter Assembly Components External Flowmeter ShownWater Intake System Equipped With Integrated Flowmeter Water IntakeMains water mixing External Flowmeter Water Mixing Water Mixing External Flowmeter11Water Path with Integrated Flowmeter Water Mixing Integrated Flowmeter12Water Inlet Mixer 13Water Hardness Mixer Solenoid Solenoid Valve Y5 Operating Plus Models OnlyElectronic Controlled Water Hardness EGS 14Water Softener Water SoftenerReactivation Gallon Quantity Reactivation CyclesTechnical Data Condenser Drying UKTOperation 15Components for the Condenser Drying System 16Control Valve Y6 Control ValveDrain Pump, Circulation Pump Level Switch Heater Heater Pressure Switch17Heater Pressure Switch Contact Positions and Current Paths 18Water Intake / Level Switch Circuit Level Switch Intake OverflowTemperature Sensor Top Solo Valve Example Turbidity Sensor ECO SensorElectronic Unit Power Outputs Electronic Modes Programming After Replacing the ElectronicCabinet Seal Replacement Locking Plate AdjustmentSide Panel Removal Service Tip4Side View, Door with Bracket Spring Bracket ReplacementCover Plate Cover Plate RemovalPlinth area with Connecting Strip Connecting Strip RemovalBasket Guide Basket Support Rollers Replacement10Stopper removal 11Exterior view of the Inner Door Panel Combination Dispenser Removal12 Fan Removal Turbothermic Fan Removal Door Panel Outer and Inner Removal To Remove the Outer Door Panel To Remove the Inner Door Panel 14Cable Holder Removal Cable Holder Removal15 Lock Removal Lock / Handle Assembly Removal16 Hinge Removal Door Hinge Removalƒ Clockwise Tighten ƒ Counterclockwise Loosen Door Tension AdjustmentMiddle Spray Arm Removal Top Spray Arm RemovalBottom Spray Arm Removal Top Spray Arm Feed Pipe RemovalMiddle Spray Arm Feed Pipe Removal Middle Spray Arm Cover Removal19Dishwasher with Flow-Through Heater Flow-Through Heater Removal20Flow-Through Heater with Seal Item Temperature Limiter ReplacementMicrofine Filter Exchange 21 Microfine Filter ReplacementWaterProof System WPS Removal 22Pressing and Locking the Filter Assembly23Tilting the Flow Restrictor WaterProof System WPS Restrictor Exchange25 Water Inlet Removal Water Inlet Diverter RemovalWater Softener Operational Check Water Softener Assembly- Removal Float Switch Housing RemovalDrip Tray Removal 26Float Switch Housing Float Switch B8/3 Removal27Steam Condenser Components Steam Condenser RemovalTemperature Sensor NTC Removal Control Valve Y6 RemovalTo prevent the possibility of a flooding condition 28Circulation Pump Removal Circulation Pump M6 Removal29Components within the Circulation Pump Circulation Pump Partition & Impeller ReplacementCirculation Pump Release with Tool Circulation Pump Housing Exchange32Turning the Circulation Pump Tool 33Heater Level Switch and Circulation Pump Heater Level Switch B1/10 RemovalDrain Pump M8 Removal 34Drain Pump Replacement35Circulation Pump with Top Solo Valve attached Top Solo Valve RemovalOverflow Level Switch Removal Sump Removal Re-Installation Service TipTurbidity Sensor Removal Turbidity Sensor Calibration39Fully Integrated Vi Control Panel Fully Integrated Vi Control Panel Removal40Control Panel Novotronic and Touchtronic Dishwashers Novotronic & Touchtronic Control Panel Removal41Removing the Fixing Bracket Fixing Bracket RemovalHeating Relay & Power Relay Removal General Information Programming and Service Mode FeaturesWater Hardness Programming Drying Options As ApplicableIncrease Temperature Fault Code RetrievalBuzzer As Applicable With or Without Water SoftenerWidth of Unit As Applicable Flowmeter CountOperating Hours Timing Charts General Information Component names and Wiring Diagram Legends are listed Timer Steps103 Program Choices and steps performed… Understanding the steps performedWiring Diagrams General Information Timing Charts & Wire Diagrams Model SpecificDoor does not close correctly Fault RepairExcess foaming Detergent not releasedNo drying or drying too slow Water leaks from the Turbothermic Fan GrillePoor drying results Circulation Pump does not start Water not heating