Miele G600, G800 manual Top Spray Arm Removal, Middle Spray Arm Removal, Bottom Spray Arm Removal

Page 71

G600 & G800 Electronic Dishwashers

Technical Information

5.15Top Spray Arm - Removal

1.Open the Door.

2.Press the Top Spray Arm upwards to engage it.

3.Unscrew clockwise.

5.16Middle Spray Arm - Removal

1.Open the Door.

2.Remove the Upper Basket.

3.Press the Middle Spray Arm upwards to engage it.

4.Unscrew clockwise.

5.17Bottom Spray Arm - Removal

1.Open the Door.

2.Remove the Lower Basket.

3.Lift up on the Spray Arm to remove it.

5.18Top Spray Arm Feed Pipe - Removal

1.Remove the left Side Panel (5.3).

2.Remove the Top Spray Arm (5.15).

3.Unscrew the Counter Nut at the Spray Arm Mount.

4.Loosen the Bottom Hose Clip on the Feed Pipe; pull off the Hose.

5.Remove the Feed Pipe from it’s Fixing Bracket by lifting upward.

71

Image 71

Contents G600 & G800 Electronic Dishwashers Technical InformationG600 & G800 Electronic Dishwashers Table of Contents Service and Maintenance……………………………………………………..57 G600 & G800 Electronic Dishwashers Table of ContentsG600 & G800 Electronic Dishwashers Table of Contents Operating Hours G600 &G800 Electronic Dishwashers List of Figures G600 &G800 Electronic Dishwashers List of Figures G600 &G800 Electronic Dishwashers List of Tables Construction and Design 2Appliance Overview Typical Fully Integrated Vi Model Unit Overview Typical Fully Integrated ModelTouchtronic Controls OverviewNovotronic Incognito 3Pre-Finished Dishwasher Types of DishwashersDishwasher Height 600 / 800 Series Technical DataDishwasher Width Fullsize / Slimline G600 Series G800 Series Summary of DimensionsElectrical Information Drain Connection Hard Wire Electrical ConnectionPlumbing Connection Intake ConnectionETL Certification -OR Data Tag9Component Overview Novotronic & Touchtronic Series Layout of Components Novotronic and Touchtronic Series10Component Overview Incognito Vi Series Incognito SeriesInstallation Horizontal Child Safety LockDoor Handle and Door Lock Novotronic and Touchtronic Series Closing the Dishwasher DoorIf the Water Softener is not needed Water SoftenerWater Softener Salt If the Water Softener is neededGeneral Operation Incognito Series General Operation Novotronic SeriesGeneral Operation Touchtronic Series PTC Release Element Units equipped with Turbothermic Fan Fan Assembly Units equipped with Turbothermic FanCabinet Construction Construction Combination DispenserDispensing Wash Cavity Heating Element HeatersFlow Through Heater Electrical Data 120VAC Flow Through Heater4Heater Circuit Heater Circuit OperationPulsed Heating Operation Temperature ProtectionStatic Drying Spray Arms Rotation Data Filter AssemblySpray Arms Water Inlet Mixer Data Water Intake Technical DataFlow Restrictor Data 6WaterProof System Connection WaterProof System WPSTechnical Information 7Water Intake Circuit Flowmeter Operation 8Flowmeter Assembly Components External Flowmeter ShownWater Intake System Equipped With Integrated Flowmeter Water IntakeMains water mixing External Flowmeter Water Mixing Water Mixing External Flowmeter11Water Path with Integrated Flowmeter Water Mixing Integrated Flowmeter12Water Inlet Mixer 13Water Hardness Mixer Solenoid Solenoid Valve Y5 Operating Plus Models OnlyElectronic Controlled Water Hardness EGS 14Water Softener Water SoftenerReactivation Gallon Quantity Reactivation CyclesOperation Technical DataCondenser Drying UKT 15Components for the Condenser Drying System 16Control Valve Y6 Control ValveDrain Pump, Circulation Pump Level Switch Heater Heater Pressure Switch17Heater Pressure Switch Contact Positions and Current Paths 18Water Intake / Level Switch Circuit Level Switch Intake OverflowTemperature Sensor Top Solo Valve Example Turbidity Sensor ECO SensorElectronic Unit Power Outputs Electronic Modes Programming After Replacing the ElectronicCabinet Seal Replacement Locking Plate AdjustmentSide Panel Removal Service Tip4Side View, Door with Bracket Spring Bracket ReplacementCover Plate Cover Plate RemovalPlinth area with Connecting Strip Connecting Strip RemovalBasket Guide Basket Support Rollers Replacement10Stopper removal 11Exterior view of the Inner Door Panel Combination Dispenser Removal12 Fan Removal Turbothermic Fan RemovalTo Remove the Inner Door Panel Door Panel Outer and Inner RemovalTo Remove the Outer Door Panel 14Cable Holder Removal Cable Holder Removal 15 Lock Removal Lock / Handle Assembly Removal16 Hinge Removal Door Hinge Removalƒ Clockwise Tighten ƒ Counterclockwise Loosen Door Tension AdjustmentTop Spray Arm Feed Pipe Removal Top Spray Arm RemovalMiddle Spray Arm Removal Bottom Spray Arm RemovalMiddle Spray Arm Feed Pipe Removal Middle Spray Arm Cover Removal19Dishwasher with Flow-Through Heater Flow-Through Heater Removal20Flow-Through Heater with Seal Item Temperature Limiter ReplacementMicrofine Filter Exchange 21 Microfine Filter ReplacementWaterProof System WPS Removal 22Pressing and Locking the Filter Assembly23Tilting the Flow Restrictor WaterProof System WPS Restrictor Exchange25 Water Inlet Removal Water Inlet Diverter RemovalWater Softener Operational Check Drip Tray Removal Water Softener Assembly- RemovalFloat Switch Housing Removal 26Float Switch Housing Float Switch B8/3 Removal27Steam Condenser Components Steam Condenser RemovalTo prevent the possibility of a flooding condition Temperature Sensor NTC RemovalControl Valve Y6 Removal 28Circulation Pump Removal Circulation Pump M6 Removal29Components within the Circulation Pump Circulation Pump Partition & Impeller ReplacementCirculation Pump Release with Tool Circulation Pump Housing Exchange32Turning the Circulation Pump Tool 33Heater Level Switch and Circulation Pump Heater Level Switch B1/10 RemovalDrain Pump M8 Removal 34Drain Pump Replacement35Circulation Pump with Top Solo Valve attached Top Solo Valve RemovalOverflow Level Switch Removal Sump Removal Re-Installation Service TipTurbidity Sensor Removal Turbidity Sensor Calibration39Fully Integrated Vi Control Panel Fully Integrated Vi Control Panel Removal40Control Panel Novotronic and Touchtronic Dishwashers Novotronic & Touchtronic Control Panel Removal41Removing the Fixing Bracket Fixing Bracket RemovalHeating Relay & Power Relay Removal Drying Options As Applicable Programming and Service Mode FeaturesGeneral Information Water Hardness ProgrammingWith or Without Water Softener Fault Code RetrievalIncrease Temperature Buzzer As ApplicableOperating Hours Width of Unit As ApplicableFlowmeter Count Timing Charts General Information Component names and Wiring Diagram Legends are listed Timer Steps103 Program Choices and steps performed… Understanding the steps performedWiring Diagrams General Information Timing Charts & Wire Diagrams Model SpecificDetergent not released Fault RepairDoor does not close correctly Excess foamingPoor drying results No drying or drying too slowWater leaks from the Turbothermic Fan Grille Circulation Pump does not start Water not heating