GE PT925 manual Cooling Fan, Ribbon Cable Assembly, To remove the cooling fan

Page 41

Cooling Fan

The cooling fan is located in a recess in the back of the oven. It is necessary to remove the oven from the installation to access the cooling fan.

The fan will begin to operate when the oven is in any cooking mode. The fan may continue to operate even after the oven is turned off.

To remove the cooling fan:

1.Remove the main rear access panel. (See Rear Access Panels.)

2.Disconnect the wire harness and the ground wire from the cooling fan.

Disconnect

Cooling Fan

3.Remove the four 1/4-in. hex-head screws (2 on each side) that hold the cooling fan to the control compartment.

4.Carefully grasp the assembly and tilt the unit back, up, and out of the oven frame.

Ribbon Cable Assembly

To remove the ribbon cable assembly:

1.Open or remove the lower door.

2.Release the ribbon cable assembly from the door. (See Door Assemblies.)

3.Remove the secondary rear access panel. (See

Rear Access Panels.)

4.Disconnect the back of the ribbon cable from the mating connector.

Disconnect

5.Remove the 4 screws and nuts from the front end of the ribbon cable housing.

6.Remove the ribbon cable by sliding it out of the ribbon cable sleeve.

Note: When installing the new ribbon cable, ensure that the new cable is positioned between the wings of the ribbon guide located between the oven cavities.

– 41 –

Page 40 Page 42
Image 41
Page 40 Page 42
Contents Technical Service Guide Important Safety Notice Table of Contents Introduction Model Number Nomenclature9 2 5 B R B B Self Clean HI/LO Pad Control FeaturesHow to Set the Upper and Lower Ovens Using the Upper and Lower OvensHow to Set the Lower Oven for Baking or Roasting How to Set an Immediate Start and Automatic Stop How to Set a Delayed Start and Automatic Stop Using the Probe on the Lower Convection Oven To Set the Kitchen Timer Using the Clock, Kitchen Timer, and Control LockTo Reset the Kitchen Timer To Cancel the Kitchen TimerControl Lock Adjusting the Upper or Lower Oven ThermostatTo Adjust the Thermostat Convection Fan Operation Using the Convection OvenIntroduction Multi-Rack Convection BakingNormal How to Set the Lower Oven for Convection Baking or RoastingUsing the Timed Features for Convection Cooking Oven turns off Unsure which setting to use Using the Slow Cook, Pizza, Warming, and Proofing FeaturesHow to Set the Lower Oven For Slow Cook How to Set the Lower Oven for Proofing How to Set the Upper Oven For PizzaHow to Set the Lower and Upper Ovens for Warming How to Delay the Start of Cleaning Using the Self-Cleaning Upper and Lower OvensHow to Set the Upper/Lower Oven for Cleaning Hour Shutdown Special Features of the Oven ControlHelp Function Tones at the End of a Timed Cycle Fahrenheit or Celsius Temperature SelectionTone Volume Auto Recipe Conversion Hour, 24-Hour or Clock BlackoutHow to Set for Regular Baking Using the Sabbath Feature lower oven onlyActive during the Sabbath feature Doesn’t appear in the display, start again at StepHow to Exit the Sabbath Feature Single Double Wall Oven Profile shown Component Locator ViewsBack of Oven Main Rear Panel Shown Removed Control CompartmentOven Oven Component Access ChartDoor Assemblies Oven ComponentsTo replace the door To remove the lower outer door assemblyTo remove the upper outer door assembly To replace the lower inner door assemblyDoor Gasket To replace the upper inner door assemblyAssembly Notes Electronic Oven Control Oven RemovalTo remove the oven To remove the electronic oven controlThere are two side panels on each side of the oven Side Access PanelsTo remove the side access panels Top Access Panels Rear Access PanelsTo remove the rear access panels To remove the top access panelsTo remove the oven temperature sensor Oven Temperature SensorDisconnect the wires from the broil element Broil ElementBake Element Disconnect the wires from the bake elementConvection Fan Blade To remove the bake elementConvection Bake Element Convection Fan Motor To remove the convection fan motor assemblyTo remove the convection bake element Red and Blue 168 Ω Red and Gray 75 Ω Blue and Gray 93 ΩRelay Boards Lock AssemblyTo remove the relay boards Door Locking/Unlocking Strip CircuitTo remove the thermal cut outs To remove the lock assemblyThermal Cut Outs To remove the sail switch Sail Switch AssemblyLock Out Relay To remove the lock out relayTo remove the ribbon cable assembly Ribbon Cable AssemblyCooling Fan To remove the cooling fanMeat Probe and Outlet Oven Light AssemblyDoor Hinge Receivers Oven Light Bulbs Pull the oven light housing from the oven linerTo remove the oven light bulb To replace the oven light bulbTo remove the upper oven smoke eliminator Smoke EliminatorsOven Circuits Electronic Oven ControlUpper Oven Relay Board Relay Boards Lower Oven Relay BoardElectronic Oven Control Control Voltage Diagnostics and Service InformationWires on J7 below small relays To enter the service mode To exit the service mode Service ModeKeypad Display Oven FunctionProblem Possible Causes What To Do Using the Ribbon Cable for TroubleshootingTurned off If 12VDC is not between pin 1 and pin 3, advance toIf the lights work properly using the keypad but not Plunger switchRelated to the bad cavity Element resistanceReplace jamb switch or check harness Convection Fan TroubleshootingOven Sensor Ohmmeter Test OpenGeneral Troubleshooting Excess soil, and reset the clean cycle Cooking and cleaning FunctionsSelf-clean cycle Has been selected, but Close the oven door Locked because Temperature insideResetting any cooking function Reset the clock. If the oven was in use, you must reset itWhen using the ovens It is normal to see Steam coming out A self-clean cycleMeaning CAUSE/CORRECTION Error CodesSchematics and Wiring Diagrams Wiring Diagram High Voltage Circuits Wiring Diagram, High Voltage CircuitsWiring Diagram, Low Voltage Circuits Wiring Diagram, Low Voltage Wiring Harness For The Period Of GE Will Replace Warranty
Related manuals
Manual 72 pages 60.71 Kb

PT925 specifications

The GE PT925 is a state-of-the-art appliance tailored to meet the demands of modern kitchens, merging advanced technology with an elegant design. This high-performance kitchen range is not just about cooking; it’s about enhancing the culinary experience through innovative features and user-friendly capabilities.

One of the standout features of the GE PT925 is its tri-ring burner, which offers versatile cooking options suitable for everything from simmering sauces to searing meats. This burner provides a wide range of heat settings, enabling chefs of all levels to achieve precise cooking results. Additionally, the appliance boasts a convection oven that utilizes a fan to circulate hot air, ensuring an even cooking temperature. This technology is particularly beneficial for baking, as it promotes uniform browning and helps reduce cooking times.

The GE PT925 is also equipped with smart technology, allowing users to control the oven remotely via a mobile app. This feature offers the convenience of preheating the oven on the way home or monitoring cooking progress from another room. The integration of Wi-Fi connectivity further enhances the user experience, making it easier to access recipes and cooking tips directly from the appliance.

Another significant characteristic of the PT925 is its durable construction. Built with high-quality stainless steel, this appliance is designed to withstand the rigors of daily use while maintaining an attractive appearance. The oven’s interior is self-cleaning, which simplifies maintenance and keeps the cooking environment hygienic.

The GE PT925 also prioritizes energy efficiency, featuring an Energy Star certification. This means it meets strict energy efficiency guidelines set by the U.S. Environmental Protection Agency, helping to reduce energy costs while being environmentally friendly.

Safety is a key consideration in its design, with features such as a child lock and automatic shut-off for added peace of mind. The high-quality knobs and controls are intuitive, providing easy access to settings without the need for complicated manuals.

In summary, the GE PT925 combines advanced cooking technologies with user-friendly features and elegant design. With its versatile burners, smart capabilities, energy efficiency, and safety enhancements, it represents an innovative solution for those looking to elevate their cooking experience at home. Whether for family dinners or entertaining guests, this range stands out as a reliable and efficient addition to any modern kitchen.
Top Page Image Contents