Zanussi ZCG 7690 manual Pressure Testing, Checking the Grill, Checking the Hotplate

Page 49

If the wiring is extended or a completely new cable fitted a 3-pin 13 amp plug should be fitted. (See Fig.4a). Connect the wires as follows:

BROWN to the Live Terminal. BLUE to the Neutral Terminal.

GREEN and YELLOW to the Earth Terminal.

As the colours of the wires in the mains lead which you fit may not correspond with the coloured markings identifying the terminals in your plug, proceed as follows:

The wire which is GREEN and YELLOW must be connected to the terminal in the plug which is marked with the letter 'E' or by

the earth symbol or coloured GREEN or GREEN and

YELLOW.

The wire which is coloured BLUE must be connected to the terminal which is marked with the letter 'N' or coloured BLACK. The wire which is coloured BROWN must be connected to the terminal which is marked with the letter 'L' or coloured RED.

FIT A 3 AMP FUSE TO THE PLUG HOLDER.

Ensure that the supply cable cannot get caught by the stability bracket.

Fig.4a

Plug in the appliance.

6. PRESSURE TESTING

1The oven injector is used as a pressure test point.

Remove the oven furniture. Remove oven burner box retaining clips (one spring clip from each side) and remove box front cover. Replace one clip back into the right hand side of the burner box.

Remove oven burner by removing the spring clip from the right hand side of the oven burner and slide burner off injector whilst easing it forward and taking care not to strain the F.S.D. phial.

2.Connect the pressure gauge to the oven injector.

3.Check the supply pressure by turning the thermostat on and one hotplate tap full on and light the appropriate burner. The pressure should be either:-

(i)For Natural Gas 20mbar

(ii)For LP.GasThe pressure must be set to 28 mbar for use on butane or 37 mbar for use on propane.

4.Turn off the taps, disconnect the pressure gauge and replace oven burner and cover, ensuring that the F.S.D. phial is correctly located into the bracket on the burner.

5.Check operation of oven.

7. CHECKING THE GRILL

Place the grill pan containing the grid, with the handle attached, into the grill compartment. Light the grill burner by turning the grill tap to its full on position and pushing the ignition button. As soon as the burner is lit the button can be released.

8. CHECKING THE HOTPLATE

Lift the lid. Fit the burner crowns and caps ensuring that they are correctly seated. Fit the pan supports. Check each of the hotplate burners in turn by turning the hotplate tap to it's full on position and pushing the

ignition button. As soon as the burners are lit the button can be released.

9. CHECKING LID SHUT-OFF DEVICE

1.Lift the lid.

2.Turn one hotplate burner tap to its full on position and push the ignition button.

3.Close lid. There should now be no gas supply to the hotplate and the burner will go out.

4.Turn off the hotplate tap and lift the lid. The gas supply should now be restored to the hotplate. When the tap is turned on.

49

Page 48 Page 50
Image 49
Page 48 Page 50
Contents ZCG Introduction For your safetyKeep children, babies and toddlers awa all times Contents Hotplate Lighting the applianceGrill Grill/second ovenSecond oven To turn off any burner Main ovenOven light Grill control has two heat settings Prior to using the grillGrill Heat controlGeneral Cooking positionsPreheating Positioning food on the gridGrill pan is supplied with a removable handle Grill pan and handleBurner sizes HotplateAre reaching across the hotplate Take care to avoid burns and scalds when youUse pans with flat bases. They are more stable Than pans which are warpedHelpful hints Heat zones OvensOven shelves Baking trays and dishes Condensation RoastingOven cooking chart Main oven Mins. per ½kg 1lb and 25 mins 30 40 mins Base Medium Oven cooking chart Second ovenLamb Shelf on Medium Base Well DoneFruit pie shortcrust 25 35 mins Baked custard 50 60 mins 45 60 minsTo use the Timer Electronic timerTo set the time of day Turn the selector knob to Manual then turn to ClockAutomatic control Setting the controls for automatic useClock. Turn Either directionHow long will Cooked by? Switch off showsFood take To cook?Hints and tips for automatic cooking Food preparation slow cooking Slow cookingPlease note There is no slow cook on the second oven Cover food with a tight fitting lid or tin foil Do not cook casseroles over 2.7kg 6lbThaw thoroughly before cooking Left over food should be cooled quickly and refrigeratedCleaning the handles and control knobs Care and cleaning For your safetyCap to crown When replacing hotplate burner partsGrill and oven furniture Ovens Main oven cleaning cycle Some staining will remain Top oven cleaning cycleTo remove the outer glass Cleaning between the outer and inner door glassInstalling the appliance Cleaning The Door GlassLocation Make sure that a stability bracket is fittedPositioning Appliance dimensionsHeight to hotplate 900mm 920mm Width 598mm DepthConnecting to the electricity supply General information For your safetyMoving your appliance Replacing the oven light bulb Check What is wrong and why?Probably a fault 7 0 5 9 2 9 9 2 Service and spare partsCustomer Care Department Installation Instructions Connections DimensionsGrill HotplateMain Oven Important Safety RequirementsSecond Oven GeneralLocation of Appliance Levelling the Appliance Parts RequiredFitting the Stability Bracket Connection to the Electricity Supply Connecting to GASChecking the Grill Pressure TestingChecking the Hotplate Checking LID SHUT-OFF DeviceChecking the Main Oven Checking the Main Oven ControlsAutomatic Operation Checking the Main Oven Light Checking the Second OvenGeneral Note Standard guarantee conditions Guarantee ConditionsT E S G 7 6 9 0 T E S Part Number311694500

ZCG 7690 specifications

The Zanussi ZCG 7690 is a versatile and efficient gas cooker designed to meet the culinary needs of modern households. Renowned for its reliability and functionality, this model combines various features that enhance cooking performance while ensuring user convenience.

One of the main features of the ZCG 7690 is its powerful gas hob. The cooker is equipped with four gas burners, providing ample space for simultaneous cooking. Each burner offers a range of heat settings, allowing users to achieve precise temperature control. The burner sizes cater to different cooking requirements, from rapid boiling to gentle simmering, making it an ideal choice for various recipes.

The design of the Zanussi ZCG 7690 is user-friendly, featuring easy-to-use rotary knobs that allow for straightforward adjustment of flame strength. Additionally, the gas burners come with an automatic ignition system, which ensures that lighting the burners is quick and hassle-free. Safety is a priority; hence, the cooker includes a flame failure device that cuts off the gas supply if the flame goes out, providing peace of mind during meal preparation.

In terms of the oven compartment, the ZCG 7690 boasts a spacious capacity that can accommodate multiple dishes at once. The oven features conventional cooking technology, ensuring even heat distribution for consistent cooking results. Users can take advantage of various cooking methods, including baking, roasting, and grilling. The oven is also equipped with a timer function, helping home chefs keep track of cooking times for different dishes.

Cleaning and maintenance of the Zanussi ZCG 7690 have been simplified with its easy-to-clean enamel oven interior and removable oven shelves. The hob surface is designed to be durable and easy to wipe, ensuring that spills and splatters do not become a hassle.

Overall, the Zanussi ZCG 7690 represents a perfect blend of functionality and style. With its robust construction, efficient gas cooking technology, and user-friendly features, it is a reliable choice for any kitchen. Whether you are preparing a quick family meal or hosting a dinner gathering, this cooker adapts to your culinary needs, making cooking enjoyable and effortless. The combination of safety features, ample cooking space, and efficient performance makes the ZCG 7690 a preferred option for both novice cooks and seasoned chefs alike.
Top Page Image Contents