Beckett SL375, SLD375, SL5125, SLD4100, SLD5125, SL7175, SL4100 Installation and Service Check List

Page 28

28

Installation and Service Check List

Boiler Model: _______________________

Serial No.: ____________________

Installation Date: ______________________

 

Installer Name: ________________________

Phone No.: ____________________

Boiler Installation

 

Boiler level and in solid contact with floor?

Boiler and burner wired per wiring diagram and National Electric Code? 120VAC wiring Type_____ Size _____ AWG

Burner sealed to boiler? Mounting nuts tight?

Space is large enough to provide required clearances?

NFPA 31 Installation of Oil Burning Equipment followed?

Local, state and national codes, laws, regulations and ordinances followed?

Vent System

Existing chimney and vent system inspected to NFPA 211 and in good condition?

New vent pipe installed and properly sealed?

Vent size checked against furnace manual and codes?

Burner Operation

Burner Model: __________________ Nozzle: _______GPH _______Deg. ____Type_______

Burner Pump Pressure: ______________

Fuel filter and fuel lines installed and inspected as per burner manual?

Air bled from oil piping? Piping checked for leaks?

Burner started, adjusted and tested per burner manual?

Boiler Operation

Thermostat heat anticipator set per burner manual instructions?

Limit control tested for proper operation?

Boiler observed going through several operational cycles for proper operation? Post Installation

Reviewed owners’ information in this manual with owner or maintenance personnel and instructed to keep for future reference?

Properly filled in and returned warranty registration card to Boyertown Furnace Co. Inserted burner manual instructions with furnace manual for future us

Image 28
Contents SL375 Thru SL7175 Be Aware of Hazard Definitions Table of Contents Ratings and Data Installation Clearances Ventilation and Combustion AirBoiler Assembly Packaged Boiler is Shipped in TWO PackagesTemperature Controls Installation and Adjustment Boiler Trim PipingJacket installation System Piping Low water cut offRelief Valves Expansion TanksVenting ChimneyChimney Connector Direct Venting Combination AIR INTAKE/VENT System Page Burner Installation Direct Vent OIL BurnersElectrical Wiring Oil Tank and PipingPage Page Swing Door OperationStart-Up Burner AdjustmentsStart-up Equipment Preliminary Burner Settings Control Circuit Safety ChecksMaintenance Oil FilterBoiler Oil BurnerDomestic Hot Water Storage Tank Vent SystemTrouble Shooting Guide Burner Will Not StartBurner Goes Off On Safety Page Solaia Residential Cast Iron Boiler Warranty Installation and Service Check List Warranty Registration Page