Nexgrill 720-0125-LP Care & Maintenance Of Side Burner, Troubleshooting, Check List, Problems

Page 23
CARE & MAINTENANCE OF SIDE BURNER

CARE & MAINTENANCE OF SIDE BURNER

BURNER CLEANING:

Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off the clog the port.

STAINLESS STEEL:

There are many different stainless steel cleaners available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface. To touch up noticeable scratches in the stainless steel, sand very lightly with dry 100 grit emery paper in the direction of the grain.

SIDE BURNER GRATE:

The top burner grate is stainless steel. To avoid burns do not clean a hot grate. They may be wiped while in place with hot, soapy water, rinsed and wiped dry. Never immerse a hot grate in water.

TROUBLESHOOTING

SPIDER AND INSECT WARNING!!!

Spiders and insects can nest in the burners of this or any other grill, and cause the gas to flow from the front of the burner. This is a very dangerous condition which can cause a fire to occur behind the valve panel, thereby damaging the grill and making it unsafe to operate.

WHEN TO LOOK FOR SPIDERS

You should inspect the burners at least once a year or immediately after any of the following conditions occur:

1.The smell of gas in conjunction with the burner flames appearing yellow.

2.The grill does not reach temperature.

3.The grill heats unevenly.

4.The burners make popping noises.

BEFORE CALLING FOR SERVICE

If the grill does not function properly, use the following checklist before contacting your dealer for service. You may save the cost of a service call.

CHECK LIST

PROBLEMS

Grill won’t light when the control knob is rotated.

WHAT TO DO

Check to see if LP tank is empty.

Clean wire(s) and/or electrode by rubbing with alcohol and clean swab.

Wipe with dry cloth.

Make sure the wire is connected to electrode assembly. Do other burners on the unit operate?

Check to see if other burners operate. If so, check the gas orifice on the malfunctioning burner for an obstruction.

Burner flame is yellow or orange, in conjunction with the odor of gas.

Low heat with knob in “HI” position.

Call our customer service line 1-800-913-8999.

Is the fuel hose bent or kinked?

Is the grill in a dusty area?

Is there adequate gas supply available?

If it is only one burner that appears low, does the orifice or burner need cleaning?

Is the gas supply, or gas pressure low?

Is the grill being preheated for 15 minutes?

21

Image 23
Contents PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE STAINLESS STEEL GAS GRILL USE AND CARE GUIDEMODEL NO.720-0125-LP DO NOT RETURN TO PLACE OF PURCHASEIMPORTANCE SECTION THREE TABLETABLE OF CONTENTSSECTION TWO SECTION ONECALIFORNIA PROPOSITION 65-WARNING PRECAUTIONSSAFETY PRACTICES TO AVOID PERSONAL INJURY TESTED IN ACCORDANCE WITH ANSI Z21.58aNEVER USE A DENTED OR RUSTY PROPANE TANK PLACEMENT OF THE GRILLDO NOT INSTALL THIS UNIT INTO COMBUSTIBLE ENCLOSURES DO NOT USE BRIQUETTES OF ANY KIND IN THE GRILLStep1: ASSEMBLY INSTRUCTIONSPLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP TheGlasso TheG T lassoM Step5 Remove the head unit of screws with four 81/4’*13mm screwsStep 6 Assemble the fortified steel to the main with 81/4’*13 Screws DO NOT TIGHTEN ASSEMBLY INSTRUCTIONSSide burner valve assembly TheG T lassoM Step 8 Assemble the door to the grill as the figure show below‰ Opening the front door and place gas tank into the gas tank holes How to install a gas tankYour gas grill is ready to use L.P. GAS HOOK-UP LEAK TESTINGGAS HOOK-UP L.P. Tank RequirementsGas flow check INSTALLER FINALBEFORE TESTING TO TESTPROPANE TANK ASSEMBLE To begin OPERATING INSTRUCTIONUSING THE GRILL General use of the grillTO LIGHT THE GRILL BURNER LIGHTING INSTRUCTIONSFlame Characteristics WARNING IMPORTANT BEFORE LIGHTING…GRILL BURNER CLEANING USING THE SIDE BURNERCARE & MAINTENANCE WARNING IMPORTANT USING THE SIDE BURNERStep 2. Push and turn one of main or side burner knobs to HI position LIGHTING ILLUSTRATIONSStep1. Make sure the lid is open Approximate 1 1/2 “ Flame Height TO MATCH LIGHT THE GRILL WHEN TO LOOK FOR SPIDERS CARE & MAINTENANCE OF SIDE BURNERTROUBLESHOOTING BURNER CLEANINGEXPLODED VIEW PARTS LIST DO NOT LEAVE THE GRILL UNATTENDED WHILE COOKING ORDERING PARTSGRILL HINTS HOW TO ORDER REPLACEMENT PARTSGRILL COOKING CHART GRILL COOKING CHART GRILL COOKING CHART PORK CHOPS BBQ SALMONBAKED CHILI CORN TANGY SEAFOOD KABOBSEGGPLANT CAVIAR VEGETABLE KABOBSFAJITAS BEEF AND LAMB KABOBSTURKEY CHICKEN TANDOORI STYLESPARE RIBS PORK ROASTComponent LIMITED WARRANTY MODEL NO. 720-0125-LPWarranty Period STAINLESS STEEL OUTDOOR GAS GRILL