Kenmore 795-71022.010 SUB PWB for Working Dispenser, Display PWB Replacement, Funnel Replacement

Page 11

2)Hold the left and right side of the “Cover Assembly, dispenser” as shown in the picture, and pull and remove it. The cover dispenser is attached with a hook.

CAUTION : When replacing the dispenser cover in the reverse order of removal, be careful that the lead wire does not come out and the water tube is not pinched by the dispenser cover, as shown in the picture below.

3-12 SUB PWB FOR WORKING DISPENSER

1) Loosen the screw on the sub PWB.

2)Pull the sub PWB down.

3)Disconnect the wire harness and replace the sub PWB in the reverse order of removal.

3-10 DISPLAY PWB REPLACEMENT

1) Pull up and out on the dispenser cover to remove.

3-13 DUCT DOOR REPLACEMENT

1) Pull up and out on the dispenser cover to remove.

2) Disconnect the wire harness.

3) Remove the funnel

4) Replace in reverse order.

2) Follow the steps in the pictures

3-11 FUNNEL REPLACEMENT

1)Pull up and out on the dispenser cover to remove.

2)Disconnect the wire harness.

3)Replace in reverse order.

- 11 -

Image 11

Contents Model #s Contents Important Notice Electrical SpecificationsInstallation Replacement PartsDescription 795.710 Parts Identification To remove the right refrigerator door Removing and Replacing Refrigerator DoorsElectrical Shock Hazard To remove the left refrigerator doorDoor Replace door frame cover Door AlignmentFAN and FAN Motorevaporator Refrigerator Compartment Lamp Defrost Control AssemblyLamp To change freezer light Multi DuctMain PWB DispenserSUB PWB for Working Dispenser Display PWB ReplacementDuct Door Replacement Funnel ReplacementAuger Motor Cover ICE Corner Door ReplacementIcemaker Assembly HOW to Insert a Door ICE BIN HOW to Remove a Door ICE BINFollow Steps to Remove HOW to Remove and Reinstall the Pullout DrawerFollow Steps to Reinstall FAN and FAN Motor Disassembly Method Water Valve Disassembly MethodHook Pull OUT DrawerRole Control of Compressor Block DiagramCompressor Introduction of E-Linear CompressorCheck to normality by measurement of resistance Compressor problems diagnosisCompressor protection logic Standard for normality Check problems by LED On & Off Count Sub PCBCheck to normality by measurement of Voltage Circuit Diagram Error Code on display panel TroubleshootingCON5 CON8 CON1 CON4 CON3CON2 Sub PCB EBR60070706 2010.02~ CON3 CON1Indicates -4F CON4 Temperature ResultTemperature For example Sensor is determined byIndicates 32F Display CON101 Temperature ResultCON4 Check the Brown to Brown Temperature ResultDefrost Heater Check the Defrost control partFuse Defrost SensorBelow 12 Change the PCB Or 5 Change the motor Check the Fan motor voltage Result SVC Action Below 10 Change the PCB Or 5 Change the motor CON5 CON5 Check the White/Red to White/Black Result SVC ActionIce Maker Geared Motor Dispenser Motor CON2 Check the resistance value Point Result SVC ActionGeared Motor Ice MakerDispenser Ice Maker Pilot Valve Result SVC Action While pushing the lever S/WCON2 Check the Blue to Gray CON3 Check the resistance value Point Result SVC ActionCON4 Check the Blue to Black Status Result SVC Action Check the Yellow Blue to Sky blue Status Result SVC ActionNormal Go to Other Change door S/W Push Infinity Page Damper For example, 23 indicates -4F Check the air temperature Status SVC Action Cold or not ?Page After measure the values, you should put in the TPA again AC TPA DC TPAPage Page How to check the Fan-Error Compressor Troubleshooting On on off on on off on on off repeating LED operating condition Cause Service guidelineLED seven- time repetiton IPM Fault Trip LED two time Repetiton Stroke TripSensor at room temperature Defrost Controller Assembly FunctionHow to Measure Sensor Standard Fuse-M at all temperatureStandard Sheath heater at all temperatureTest Point Ressult Measure Button Plunger Beep Standard Multimeter beep Switch F,RSwitch, Refrigerator Dispenser DC Motor Function Cube Solenoid Standard Geared MotorStandard Damper Test Points Result To 2 and 3 to Flow Sensor Function How to MeasureVvvf Information of Linear CompressorCvcf FCT0 Multi Tester IPM Voltage CheckLG Linear Compressor Inf ~ ~ 8 Ω ~ 8 Ω Inf ~ FC75LANEComplaint Points to be Checked Remedy Service Diagnosis ChartRefrigeration Cycle Troubleshooting ChartVery Fast PartialFrostOperation Principle Stage Time to Supply Indications Remarks ICE Maker FunctionsWater supply amount Table Defect Diagnosis Function Stage Items Indicator RemarksDivision Indicator Contents Remarks Lock function dispenser and display button lock How to Toggle the Display between F & CFunction FunctionIce Compartment Fan Ultra Ice selectionDispenser use selection Cooling Fan MotorUltra Ice Alarm for Open DoorHow to set the display mode and cancel It Defect Diagnosis Function Defrosting removing frost617A 625A 616G 623B Case Parts Case Parts Case Parts Freezer Parts Refrigerator Parts Door Parts Door Parts Dispenser Parts ICE Maker & ICE Bank Parts