Craftsman 917.271653 owner manual To Adjust Brake, To Replace Motion Drive Belt, Belt Removal

Page 23

Mandrel

Idler

Pulley

TO ADJUST BRAKE

Your tractor is equipped with an adjust- able brake system which is mounted on the right side of the transaxle.

If tractor requires more than six (6) feet stopping distance at high speed in highest gear on a level dry concrete or paved surface, then brake must be adjusted.

1.Depress clutch/brake pedal and engage parking brake.

2.Measure distance between brake

operating arm and nut =A" on brake rod.

3.If distance is other than 1-1/2", loosen jam nut and turn nut "A" until distance becomes 1-1/2". Retighten jam nut against nut "A".

4.Road test tractor for proper stopping distance as stated above. Readjust if necessary. If stopping distance is still greater than six (6) feet in highest gear, further maintenance is neces- sary. Contact a Sears or other qualified service center.

With Parking Brake "Engaged"

Nut =A"

Nut

ting

Aim

TO REPLACE MOTION DRIVE BELT

Park the tractor on level surface. Engage parking brake. For assistance, there is a

belt installation guide decal on bottom side of left footrest.

BELT REMOVAL -

1. Remove mower (See "TO REMOVE

MOWER" in this section of manual). NOTE: Observe entire motion drive belt

and position of all belt guides and keepers.

2.Remove belt from stationary idler and clutching idler.

3.Remove belt downward from around engine pulley.

4.Pull belt slack toward rear of tractor. Remove belt upwards from transaxle pulley by deflecting belt keepers.

5.Remove belt from center span keeper and pull belt away from tractor.

BELT INSTALLATION -

1.Carefully work new belt down be- tween transaxle belt keepers and onto the input pulley.

2.Slide belt into the center span keeper.

3.Pull belt toward front of tractor and roll around the top groove of engine pulley.

4.Install belt through stationary idler and clutching idler.

5.Make sure belt is in all pulley grooves

and inside all belt guides and keep- ers.

6.Install mower (See "TO INSTALL

MOWER" in this section of manual).

Engine Pulley_

ciiiii::iI t

23

Image 23
Contents Am 5 pro, Mon- Sat Sears Craftsman Help LineLimited Warranty on Battery Limited Warranty on Craftsman Riding EquipmentI1. Slope Operation General OperationDo not IV. ServiceMow up and down slopes, not across Page SAE Product SpecificationsRepair Agreement Customer Responsibilities17/32 x 1-3/16 x 12 Gauge Steering Wheel Hex Bolt Steering3/8-16x Wheel InsertLocknut 1/2-20 SeatBefore Removing Tractor from Skid Tools Required for AssemblyTo Remove Tractor from Carton Adjust seat before tightening adjustment knob Install SeatCheck Deck Levelness Install Mulcher PlateTo Convert to Bagging or Discharging Check Tire PressureH L Knowyourtractor Clutch/Brake Indicator PedalTo Move Forward and Backward Howto UseyourtractorTo SET Parking Brake To USE Throttle ControlTowing Carts and Other ATTACH- Ments To Operate MowerTo Operate On Hills To TransportTo Start Engine Adjustments section of this manualADD Gasoline Mulching Mowing Tips Mowing TipsSection Lubrication ChartBeforeeachuse General RecommendationsOperator Presence System BatteryBrake Operation TiresEngine BeltsMuffler Clean AIR ScreenCleaning Engine Cooling FinsBoth Sides Service or AdjustmentsTo Install Mower To Remove MowerTo Replace Mower Blade Drive Belt To Level Mower HousingSIDE-TO-SIDE Adjustment FRONT-TO-BACK AdjustmentBelt Removal To Adjust BrakeTo Replace Motion Drive Belt To Remove Wheel for Repairs Transaxle Gear Shift Lever Neutral AdjustmentTo Adjust Steering Wheel Alignment Front Wheel TOE-IN/CAMBERInterlocks and Relays Replacing BatteryTo Remove Hood and Grill Assembly To Replace Headlight BulbHoles a Throttle To Adjust Throttle Control CableTo Adjust Carburetor EngineOther Fuel SystemEngineoil CylindersCorrection Troubleshooting ChartProblem CauseProblem Cause Correcon Troubleshooting ChartImproper blades used Problem Cause CorrectionLevel UnderTractor - Model Number Schematic Electrical KEY Part Description Tractor - Model Number ElectricalTractor - Model Number Chassis and Enclosures Tractor -- Model Number 917.271653 Chassisand Enclosures Tractor - Model Number Ground Drive Tractor - Model NUM BER Tractor - Model Number 917.271653 Steering Assembly 160367 Tractor - Model Number Steering AssemblyKEY Part Tractor - Model NumberEngine Optional Equipment Spark ArresterKEY Part NO. NO. Description Tractor - Model Number Lift Assembly2O2O 14 72050412 Bolt Rdhd Sht Nk 1/4-20x1-1/2 Tractor --MODEL Number Seat AssemblyTractor - Model Number Decals Tractor - Model Number Mower Deck 72140614 Tractor --MODEL Number Mower Deck5950 Part KEY Description 757 883 276 1127 711 467971 I601240 176 404@ Label KIT Ownersmanual 127 186 1421 202 562 267LABEL-EMISSIONS 5803121A Carburetor Overhaul KIT Carburetor Overhaul KITValve Gasket SET Engine Gasket SETAir Cleaner 729 Page Suggested Guide for Sighting Slopes for Safe Operation A. and Canada Anytime, day or night