Craftsman 141, 385 Loss Power, Poor Cut, Vibration, Starter rope, Hard To pull, Grass Catcher

÷

TROUBLESHOOTING = See appropriate section in manual unless directed

to a Sears Parts & Repair Center.

PROBLEM

CAUSE

CORRECTION

Loss

of power

1.

Rear

of mower

housing

or

1.

Raise

cutting

height.

blade

dragging

in grass.

2.

Cutting

too

much

grass.

2.

Raise

cutting

height.

3.

Dirty

air

filter.

3.

Clean/replace

air

filter.

4.

Buildup

of grass,

leaves,

4.

Clean

underside

of mower

and

trash

under

mower.

housing.

5.

Too

much

oil in engine.

5.

Check

oil level.

6.

Walking

speed

too

fast.

6.

Cut at slower

walking

speed.

Poor

cut-

1.

Worn,

bent

or

loose

blade.

1.

Replace

blade.

Tighten

uneven

blade

bolt.

2.

Wheel

heights

uneven.

2.

Set all

wheels

at same

height.

3.

Buildup

of grass,

leaves

3.

Clean

underside

of

and

trash

under

mower.

mower

housing.

Excessive

1.

Worn,

bent

or

loose

blade.

1.

Replace

blade.

Tighten

vibration

blade

bolt.

2.

Bent

engine

crankshaft.

2.

Contact

a

Sears

or other

qualified

service

center.

Starter rope

1.

Engine

flywheel

brake

is on

1.

Depress

control

bar

to

hard

to pull

when control

bar

is released.

upper

handle

before

pulling

the

starter

rope.

2.

Bent

engine

crankshaft.

2.

Contact

a

Sears

or other

®

qualified

service

center.

3.

Blade

adapter

broken.

3.

Replace

blade

adapter.

4.

Blade

dragging

in

grass.

4.

Move

lawn

mower

to cut

grass or to hard surface.

Grass

catcher

1.

Cutting

height

too

low.

1.

Raise

cutting

height.

not filling

2.

Lift on

blade

worn

off.

2.

Replace

blade.

(if so

equipped)

3.

Catcher

not venting

air.

3.

Clean

grass

catcher.

Hard

to push

1.

Grass

is too

high

or wheel

1.

Raise

cutting

height.

height

is

too

low.

2.

Rear

of mower

housing

or

2.

Raise

rear

of

mower

housing

blade

dragging

in grass.

one

(1)

setting

higher.

3.

Grass

catcher

too

full.

3.

Empty

grass

catcher.

4.

Handle

height

position

not

4.

Adjust

handle

height

to suit.

right

for

you.

17

L

®

385141-es-412842_r0indd 17 4_ 2/23/2007 10:58:16AM