Sears 917.25591 manual Clutch/Brake, Clutch Position Brake Shaft, IFT Lever, Full

Page 6

DIPSTICK

 

ENGINE

 

FIGURE7

 

 

"CLUTCH/BRAKE"

PARKING

BRAKE

"ENGAGED"

POSITION

POSITION

 

 

ct

 

"CLUTCH" POSITION

BRAKE

 

SHAFT

FIGURE

8

ATTACHMENT

IGI_

_'HRDTTLE

KEY

CONTROL

CHOKE

PARKING

BRAKE

"RANGE

IFT

LEVER

GEAR SHIFT

CONTROL LEVER

FIGURE 9

8NUTIIAL SERVICE

1.This engine hag been shipped filled with oil. Check Engine

Oil Level with Tractor on level ground., Wipe Dipstick

(Fig,

7) clean,

push it

in tight for

a few seconds,

remove

and

read Oil

Level.

If

necessary,

.

. ,

FULL

t_

mark

is reached,

add Oil

until

 

 

 

 

 

 

 

RECOMMENDED SAE VISCOSITY GRADES

I I I J 1301I.J_LJ_-L--1

-20°

0°

32 °

60 °

80 °

100 °

TEMPERATURE RANGE EXPECTED BEFORE NEXT OIL

CHANGE, ALL OILS MUST MEET A.Po/. SERVICE CLAS- StFICATION SD, SE, OR SF.

Capacity is 3 pints. NOTE: DO NOT OVERFfLL Dipstick assembly must be securely tightened into tube at all times when engine is operating°

2, Fitl

,

Fuel Tank (Fig, 6)r, Use fresh, clean, unleaded auto-

 

 

.

ne_ (Leaded

II

Regular

I

.

mot ve gasol

 

 

 

grade gasoline is an

acceptable substitute, but will increase carbon and lead

oxide deposits and reduce valve tife)_ Capacity is 3 - 1/2 gallons_

WARNING: DO NOT USE GASOHOL OR METHANOL. These type fuels react with water content in the fuel and tend to form strong acids which can corrode metal parts and harm rubber and plastics,,

FILL TO BOTTOM OF GAS TANK FILL-

ER NECK° DO NOT OVERFILL, WIPE

OFF ANY SPILLED OIL OR FUEL. DO

NOT STORE, SPILL OR USE GASOLINE

NEAR AN OPEN FLAME.

3, Reduce Tire pressure to 14 PSI in front and t0 PSI in rear' Tires, (Tires were overinflated for'shipping purposes),

4, Remove bands from Mower Suspension Bracket (Fig. 11),

STARTING THE ENGgNE

YOUR TRACTOR IN A LARGE, OPEN

[ _!_ AREALEARNTOSTART,STOPANDREVERSE.

NOTE: THIS TRACTOR IS EQUIPPED WITH INTER LOCK SWITCHES TO PREVENT STARTING OF THE TRACTOR

ENGINE WHILE THE ATTACHMENT CLUTCH OR THE TRACTOR CLUTCH IS ENGAGED.

IMMEDIATELY REPLACE SWITCHES

THAT ARE NOT IN PROPER WORKING

ORDER. DO NOT ATTEMPT TO DEFEAT

THE PURPOSE OF THESE SWITCHES.

1, Place Attachment Clutch Switch in "DISENGAGED" position (Fig. 9),

2.Push Clutch-Brake Pedal fully into brake position (Fig. 8),

Place Gear Shift Control Lever- in "N" neutral, start posi- tion and Range Shift Lever in "N" neutral posltion (Fig. 9)o

Page 5 Page 7
Image 6
Page 5 Page 7
Contents 8EA/RS TRANSMISSION-six speedsforward Full SO-DAY Warranty on BatteryLarge variety ScuffingRules for Safe Operation Wash Hands or Clothing Immedi Install BatteryWear EYE and Face SHtELD Ately tF Accidentally in ContactClose Hood Intjext Wing Wing NUT LockwasherPosition Temperature Range Expected Before Next OILCLUTCH/BRAKE Clutch Position Brake ShaftTOR to Prevent Unauthorized Remove KEY When Leaving TracOUT the Deflector Shield 1N Do not Operate the Mower with Avoid Stopping or Shifting on HillsMower and Drive Belt Stallation Each PulleyWasher Retaining Washer Clip Lift LinkHandle Rear Suspensionmower Bracketsbracket Release PIN Driveway, Make sure tire pressures are 14 PSI in front Adjust the mower while tractor is parked on level ground orFiairpin Clip PSI in rearTo Raise Frontof Mower To Lower Front of MowerMower Engagement Deflector Tire Chains Cannot be Used with the Mower Housing ATTACHED=RoH,RUNNER Never Remove DEFLECTOR. Keep Hands and Feet from Under MOWBlade Replacement Lutely Sure the Blades and ALlEN Securely Always USE Grade 5 Heat Treated Clutch Cleanng MowerPower TA/KE= Prevent Accidental Starting beOuter Blades Drive Belt From TractorJAM NUT Dischargingcharging Attachment Loft AdjustmentStorage AmperesChange Engine OIL DipstickEvery 15 Hours if Operating in Very Dusty Conditions Moved AS Dirt Dust will Damage the Engine Clean AIR ScreenClean Front Grill Lubricate Steering and Front WheelsLubricating Grease Amdex NO, t, Sears Part no R 8o Clean Battery and TerminalsClean Engine Cooling Fins Refer to Engine OIL SPECS. Under Initial PreparationLubricate Ball Joints Replace AIR Cleaner Paper Cartridge Refer toReplace Spark Plugs Replace IN*LINE Fuel FilterIf Tractor Requires More than Brake AdjustmentCheck Transaxle OIL Level TUGTAKE. UP Idler Refer to Starting the EngineBelt Removal 10, Hood Removal AS YOU CompleteFinish DatesPossible Cause Will not Start Engine Misses or Lacks PowerGeneral Cleaning Hard to StartOrange Light Switch Ignition SwitchRED Diode Assembly Engine Coil STARTB-S BlackStandard KEY Part Description NO. no Descr Iption29 719J Washer Lock 3/8Repair Parts KEY L M N O P Q R @11 82 UGarden TRACTOR-MODEL Repar Parts 22t85GT 18 Twin Garden TRACTOR-MODEL Number 917,255910 PartC D E Mower L ! FT Bracket, Lift LiftPump, Fuet Standard HARDWARE-PURCHASERepair PT8 C D E F G REPAmR Parts Reduction Gear Shaft 7398H GT 18 Twin Garden TRACTOR--MODEL Number Transaxle4216R Differential Gear 8119M Extra Heavy 101444XRepahr Parts KEY Part NO, no Description KEY PartRpair Parts KEY Part NO. no 223 Part Description KEY222849 Cover Air Guide 222846 392681 Housing- Blower222848 Cover Air Guide 222847 93163 Screw- Sere 93777Servics Notes Sight and Hold Thss Level with SKY LaNE or TreeGT 18 Twin Speed Garden Tractor

917.25591 specifications

The Sears 917.25591 is a robust lawn tractor that has earned a solid reputation among gardening enthusiasts and homeowners alike. Known for its reliability and impressive features, this model is ideal for tackling various landscaping tasks, from mowing to hauling. One of the standout characteristics of the 917.25591 is its powerful engine. Typically equipped with a Briggs & Stratton engine, this lawn tractor delivers the performance needed to handle tough grass and uneven terrain with ease. The engine provides a good balance between power and fuel efficiency, making it a practical choice for regular lawn maintenance.

Another key feature of the Sears 917.25591 is its cutting deck. With a generous width, the deck allows for efficient mowing, reducing the number of passes needed to maintain a well-groomed lawn. The adjustable cutting height settings provide versatility, enabling users to customize their mowing experience based on grass type and seasonality.

User comfort is also paramount in the design of the 917.25591. The adjustable seat ensures that operators can find their ideal position, making long hours of mowing more manageable. The ergonomic controls are intuitively placed, allowing for easy operation while minimizing fatigue. Additionally, the tractor's tight turning radius enables maneuverability around flower beds and tight spaces, ensuring that every nook of your landscape is tended to.

One of the advanced technologies integrated into the Sears 917.25591 is its automatic transmission. This feature eliminates the need for manual gear shifting, allowing for a smoother driving experience. The transmission system seamlessly adapts to changing terrains and mowing conditions, ensuring optimal performance at all times.

The sturdy construction of this lawn tractor also means it is built to last. Made from high-quality materials, it withstands the rigors of frequent use, making it a worthwhile investment for anyone serious about lawn care. Furthermore, available attachments such as baggers and snow plows make the Sears 917.25591 a versatile machine that extends its functionality beyond just mowing.

In summary, the Sears 917.25591 is a well-rounded lawn tractor that combines a powerful engine, user-friendly features, advanced technologies, and durable construction to meet the needs of any homeowner or gardener. Its reliable performance and versatility have made it a popular choice for those looking to maintain a beautiful outdoor space.
Top Page Image Contents