Sears 917.25591 manual Replace Spark Plugs, Lubricate Ball Joints, Replace IN*LINE Fuel Filter

Page 20

CLEAN AREA

OF ALL DIRT

AND DEBRIS

FIGURE 41

GAUGE

PLUG

FIGURE 42

TIE ROD

BALL JOINTS

TIE ROD

JAM NUTS

STEERING LINK

BOOT

FIGURE 43

HOSE

CLAMPS

FUEL FILTER

svs.vI]®® .o..s

1.REPLACE SPARK PLUGS

Replace Spark Plugs at the beginning of each season or every 100 hours_ whichever comas first. Gap should be set at .030 inch (Fig. 42).

2_ LUBRICATE BALL JOINTS

aMove Rubber Boots to expose Ball Joints on Tie Rods

and Steering Link (Fig. 43)_

b. Coat Ball Joints with Silicone Spray Lubricant c. Reposition Rubber Boots_

Ew.v .o..s

1_ REPLACE AIR CLEANER PAPER CARTRIDGE Refer to page 18,

2.REPLACE IN*LINE FUEL FILTER

a, Remove Hose Clamps from Fuel Lines at Fuel Filter

(Fig_ 44),

b.Remove Fuel Filter°

co Place new Fuel Filter in position with fuel line (arrow on side of Filter in direction of Fuel Filter) and reinstall

Hose Clamps.

BE SURE THERE ARE NO FUEL LINE

LEAKS AND THAT HOSE CLAMPS ARE

PROPERLY INSTALLED.

1o CHANGE TRANSAXLE OIL

ao Block up Rear Axle (Fig. 45) securely or use a Tractor' Jack. Remove left Rear Wheel by removing Hub Bolts. b. Drain Transaxle Oil by removing Drain and Filler Plugs (Fig's. 45 & 47) and catching Oi! in suitable container..

Replace Drain Plug.

c, Refill Transaxle with S=A..E 30 (SC, SD or SE) Motor Oi!o Capacity is 5 quarts. Pressure Relief Valve (R..H side of Transaxle) (Fig. 45 - Inset) may be held open to allow Transaxie to fill more quickly.

do Check Pressure Relief Valve° It should spring completely closed when pulled out by hand and released.

eo Reposition wheel. Secure with Hub Bolts.

LH. SIDE

PLUG

FIGURE 44

- 20-

FIGURE 45

Page 19 Page 21
Image 20
Page 19 Page 21
Contents 8EA/RS Full SO-DAY Warranty on Battery Large varietyTRANSMISSION-six speedsforward ScuffingRules for Safe Operation Install Battery Wear EYE and Face SHtELDWash Hands or Clothing Immedi Ately tF Accidentally in ContactClose Hood Intjext Wing Wing NUT LockwasherTemperature Range Expected Before Next OIL CLUTCH/BRAKEPosition Clutch Position Brake ShaftRemove KEY When Leaving Trac OUT the Deflector Shield 1N Do not Operate the Mower withTOR to Prevent Unauthorized Avoid Stopping or Shifting on HillsMower and Drive Belt Stallation Each PulleyHandle Rear Suspensionmower Bracketsbracket Release PIN WasherRetaining Washer Clip Lift Link Adjust the mower while tractor is parked on level ground or Fiairpin ClipDriveway, Make sure tire pressures are 14 PSI in front PSI in rearMower Engagement To Raise Frontof MowerTo Lower Front of Mower Tire Chains Cannot be Used with the Mower Housing ATTACHED= RoH,RUNNERDeflector Never Remove DEFLECTOR. Keep Hands and Feet from Under MOWEN Securely Always USE Grade 5 Heat Treated Blade ReplacementLutely Sure the Blades and ALl Cleanng Mower Power TA/KE=Clutch Prevent Accidental Starting beOuter Blades Drive Belt From TractorAttachment Loft Adjustment StorageJAM NUT Dischargingcharging AmperesChange Engine OIL DipstickMoved AS Dirt Dust will Damage the Engine Clean AIR Screen Clean Front GrillEvery 15 Hours if Operating in Very Dusty Conditions Lubricate Steering and Front Wheels8o Clean Battery and Terminals Clean Engine Cooling FinsLubricating Grease Amdex NO, t, Sears Part no R Refer to Engine OIL SPECS. Under Initial PreparationReplace AIR Cleaner Paper Cartridge Refer to Replace Spark PlugsLubricate Ball Joints Replace IN*LINE Fuel FilterBrake Adjustment Check Transaxle OIL LevelIf Tractor Requires More than TUGTAKE. UP Idler Refer to Starting the EngineBelt Removal AS YOU Complete Finish10, Hood Removal DatesEngine Misses or Lacks Power General CleaningPossible Cause Will not Start Hard to StartIgnition Switch RED Diode Assembly Engine Coil STARTB-SOrange Light Switch BlackKEY Part Description NO. no Descr Iption 29 719JStandard Washer Lock 3/8Repair Parts KEY L M N O P Q R @11 82 UGarden TRACTOR-MODEL Repar Parts 22t85C D E GT 18 Twin Garden TRACTOR-MODEL Number 917,255910Part Mower L ! FT Lift Pump, FuetBracket, Lift Standard HARDWARE-PURCHASERepair PT8 C D E F G REPAmR Parts GT 18 Twin Garden TRACTOR--MODEL Number Transaxle 4216R Differential Gear 8119MReduction Gear Shaft 7398H Extra Heavy 101444XRepahr Parts KEY Part NO, no Description KEY PartRpair Parts KEY Part NO. no 223 Part Description KEY392681 Housing- Blower 222848 Cover Air Guide 222847222849 Cover Air Guide 222846 93163 Screw- Sere 93777Servics Notes Sight and Hold Thss Level with SKY LaNE or TreeGT 18 Twin Speed Garden Tractor

917.25591 specifications

The Sears 917.25591 is a robust lawn tractor that has earned a solid reputation among gardening enthusiasts and homeowners alike. Known for its reliability and impressive features, this model is ideal for tackling various landscaping tasks, from mowing to hauling. One of the standout characteristics of the 917.25591 is its powerful engine. Typically equipped with a Briggs & Stratton engine, this lawn tractor delivers the performance needed to handle tough grass and uneven terrain with ease. The engine provides a good balance between power and fuel efficiency, making it a practical choice for regular lawn maintenance.

Another key feature of the Sears 917.25591 is its cutting deck. With a generous width, the deck allows for efficient mowing, reducing the number of passes needed to maintain a well-groomed lawn. The adjustable cutting height settings provide versatility, enabling users to customize their mowing experience based on grass type and seasonality.

User comfort is also paramount in the design of the 917.25591. The adjustable seat ensures that operators can find their ideal position, making long hours of mowing more manageable. The ergonomic controls are intuitively placed, allowing for easy operation while minimizing fatigue. Additionally, the tractor's tight turning radius enables maneuverability around flower beds and tight spaces, ensuring that every nook of your landscape is tended to.

One of the advanced technologies integrated into the Sears 917.25591 is its automatic transmission. This feature eliminates the need for manual gear shifting, allowing for a smoother driving experience. The transmission system seamlessly adapts to changing terrains and mowing conditions, ensuring optimal performance at all times.

The sturdy construction of this lawn tractor also means it is built to last. Made from high-quality materials, it withstands the rigors of frequent use, making it a worthwhile investment for anyone serious about lawn care. Furthermore, available attachments such as baggers and snow plows make the Sears 917.25591 a versatile machine that extends its functionality beyond just mowing.

In summary, the Sears 917.25591 is a well-rounded lawn tractor that combines a powerful engine, user-friendly features, advanced technologies, and durable construction to meet the needs of any homeowner or gardener. Its reliable performance and versatility have made it a popular choice for those looking to maintain a beautiful outdoor space.
Top Page Image Contents