TROUBLESHOO=['mNG POINTS
i i i,,i,ii,,, | i i i i,ill,,,in,i |
PROBLEM
Will not start
i | _ll n in 'HII |
Hard to start
CAUSE
1Out of fuel
2Engine not "CHOKED" properly
3Engine f!ooded
4Bad spark piug
5, Dirty air filter
6Dirty fuel filter. 7, Waterin fuel
8, Loose or damaged wiring
9Carburetor out of adjustment.
10Engine valves out of adjustment
1Dirty air filter
2Badspark plug
3.Weak or dead battery
4.Dirty fuel filter,
5.Stale ordirty fuel
6Loose or damaged wiring,
7Carburetor out of adjustment
8Engine valves out of adjustment
CORRECTION
l r Fill fuel tank,
2, See "TO START ENGINE" in Operation section 3, Wait several minutes before attempting to start 4 Replace spark plug
5, Clean!replace air filter, 6 Replace fuel filter.
7, Drain fuel tank and carburetor, refill tank with fresh gasoline and replace fuel filter,
8Check all wiring
9Contact an authorized service centerldepartment,
10 Contact an authorized service center/department.
1, Clean/replace air filter, 2, Replace spark plug,
3Recharge or replace battery,
4Replace fuel filter
5Drain fuel tank and refill with fresh gasoline
6Checkalf wiring
7Contact an authorized service center/department.
8Contact an authorized service center/department,
Engine will not turn over
i , i,_,l,_ll,,,i
Engine clicks but will not start
Loss of power
_luiiuJiH_ | i i i i illl,i, |
t, Clutch!brake pedalnot depressed
2Attachment clutchis engaged
3Weak or dead battery
4Blown fuse
5Corroded battery terminals
6, Loose or damaged wiring. 7, Faulty ignition switch,
8, Faultysoleno{d orstarter
9, Faulty operator presence switch(es)
................................i, nlUl,,i
1Weak or dead battery,
2Corroded battery terminals.
3Loose or damaged wiring
4Faulty solenoid or starter
1Cutting too much grass/too fast,
2Throttle in "CHOKE" position
3,
5.Low o_1level/dirty oi_ 6, Fauityspark pkJg
7DirtyfueI filter
8, Stale or dirty fuel, 9, Waterin fuel,
10 Spark plug wire _oose.
!1 Dirty engine air screen/fins
I2 Dirty/clogged muffler.
13, Loose or damaged wiring 14., Carburetor out of adjustment t5. Engine vatves out of adjustment
1, Depress clutch/brake pedal,
2Disengage attachment clutch
3Recharge or replace battery
4, Replace fuse,
5, Clean battery terminals 6, Check all wiring,,
7 Check/replace ignition switch
8, Check/replace solenoid or starter.
9, Contact an authorized service centerldepartment
1Recharge or replace battery
2Clean battery terminals
3Check allwiring
4, Check/replace solenoid or starter,
1.Set in "Higher Cut" position!reduce speed
2 Adjust throttte controt
3 Clean underside of mower housing,
4Clean/replace air filter.
5Checkoitlevet!change oil,
6, Clean and regap or change spark ptug
7, Replace fuel f{Iter
8, Drain fuel tank and refilr with fresh gasoline.
9Drain fuel tank and carburetor, refill tank with fresh gasoline and replace fuet filter,
10Connect and tighten spark plug wire
11Clean engine air screen/fins
12, Cleantreplace muffler I3, Check alt wiring
14 | Contact | an | authorized | service | center/department, |
15, | Contact | an | authorized | service | centertdepartment |
Excessive vibration | 1 | Worn, | bent | orfoose blade |
| 2 | Bent | blade | mandrel, |
| 3. | Loose/damaged part(s) | ||
1. Replace blade Tighten blade bert |
2, Replace blade mandrel
3 Tighten loose part(s) Replace damaged parts,
29