Woods Equipment STR60S-2 manual Safety Rules, Attention! Become Alert! Your Safety Is Involved

Page 6
„Watch for hidden hazards on the terrain during operation.

SAFETY RULES

ATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED!

(Safety Rules continued from previous page)

„Watch for hidden hazards on the terrain during operation.

„Stop power unit and equipment immediately upon striking an obstruction. Turn off engine, remove key, inspect, and repair any damage before resuming operation.

MAINTENANCE

„Before dismounting power unit or performing any service or maintenance, follow these steps: disengage power to equipment, lower the 3-point hitch and all raised components to the ground, operate valve levers to release any hydraulic pres- sure, set parking brake, stop engine, remove key, and unfasten seat belt.

„NEVER GO UNDERNEATH EQUIPMENT. Never place any part of the body underneath equipment or between moveable parts even when the engine has been turned off. Hydraulic system leak-down, hydraulic system failures, mechanical failures, or movement of control levers can cause equipment to drop or rotate unexpectedly and cause severe injury or death.

•Service work does not require going under- neath.

•Read Operator's Manual for service instruc- tions or have service performed by a qualified dealer.

„Always wear relatively tight and belted clothing to avoid getting caught in moving parts. Wear sturdy, rough-soled work shoes and protective equipment for eyes, hair, hands, hearing, and head; and respirator or filter mask where appropriate.

„Make sure attachment is properly secured, adjusted, and in good operating condition.

„Keep all persons away from operator control area while performing adjustments, service, or maintenance.

„Tighten all bolts, nuts, and screws to torque chart specifications. Check that all cotter pins are installed securely to ensure equipment is in a safe condition before putting unit into service.

„Make sure all safety decals are installed. Replace if damaged. (See Safety Decals section for location.)

STORAGE
„Block equipment securely for storage.
„Keep children and bystanders away from stor- age area.

™

6Safety

STR48-72 Safety Rules (Rev. 7/28/2005)

Page 5 Page 7
Image 6
Page 5 Page 7
Contents Tested. Proven. Unbeatable Super Turf Renovator & SeedboxSTR48S-2 STR60S-2 STR72S-2 MAN0101TO THE DEALER 2 IntroductionSerial Number see Safety Decal section for location TO THE OWNERTABLE OF CONTENTS IntroductionLEA EL INSTRUCTIVO GENERAL INFORMATION SPECIFICATIONS4 Introduction Super Turf RenovatorATTENTION! BECOME ALERT! YOUR SAFETY IS INVOLVED SafetySAFETY RULES „ Never allow riders on power unit or attachmentService work does not require going under- neath 6 SafetyMAINTENANCE STORAGEUse a clean, damp cloth to clean safety decals SAFETY & INSTRUCTIONAL DECALSReplace Immediately If Damaged Safety Decals continued on next pageENTANGLEMENT AND FALLING HAZARD 8 SafetySafety Decals continued from previous page FALLING OFF CAN RESULT IN BEING RUN OVERSuper Turf Renovator Roller Operation OperationOPERATION Front RollersTractor Stability 10 OperationOperation Attach Super Turf Renovator to TractorAdjust Front Roller Angle NOTE The seed control chart should be used as a general guide onlySeeding Operation 12 Operation Operating TipsPre-Operation Check List Calibrating the STR for unlisted seed or seed blends SEEDING RATE CHARTProcedure EquipmentCleaning 14 Owner ServiceOWNER SERVICE Lubrication InformationInstall Seedbox AssemblyASSEMBLY Install Drive Sprocket16 Assembly Install Roller ChainsSeedbox Kit PartsSuper Turf Renovator PARTS INDEX18 Parts STR48S-2, STR60S-2 & STR72S-2 MAIN ASSEMBLYSTR48S-2, STR60S-2 & STR72S-2 MAIN ASSEMBLY PARTS LIST 20 Parts STR48-2, STR60S-2 & STR72S-2 SEEDBOX ASSEMBLYSTR48-2, STR60S-2 & STR72S-2 SEEDBOX PARTS LIST 22 Parts STR48-2, STR60S-2 & STR72S-2 DRIVE ASSEMBLYDESCRIPTION STR48-2, STR60S-2 & STR72S-2 QUICK HITCH KITPART Quick hitch sleeveSAE SERIES A TORQUE CHART BOLT TORQUE CHART24 Appendix CHARTABBREVIATIONS BOLT SIZE CHARTAppendix SAE Bolt Thread SizesWARRANTY F-8494 Rev. 6/23/2005Part or Woods Equipment Company2606 South Illinois Route Post Office Box Oregon, Illinois 61061 USA Model NumberMAN0101
Top Page Image Contents