National Mower HY70OM-8/992 owner manual National Mower Safe Operation Practices For Riding Mowers

Page 3

NATIONAL® HYDRO 70" TRIPLEX

IMPORTANT

National Mower Safe Operation Practices

For Riding Mowers

1.Know control functions and how to stop quickly. READ THE OWNER’S MANUAL.

2.Do not allow children to operate the mower. Do not allow adults to operate the mower without proper instruction.

3.Do not carry passengers. Keep children and pets at a safe distance from an operating mower.

4.Clear the work place of objects which might be picked up by the blades and thrown.

5.To start engine, operator must be seated, reel control must be disengaged and foot control must be in neutral.

6.Take all possible precautions when leaving the mower unattended, such as shifting into neutral, stopping the engine and removing the ignition key.

7.Do not stop or start suddenly when going uphill or downhill. Use extreme caution when mowing on slopes.

8.Reducetravelspeedonslopesandinsharpturnstopreventtippingorlossofcontrol. Useextremecaution when changing direction on slopes.

9.Watch for holes in the terrain and other hidden hazards.

10.Watch for dangerous traffic when crossing or near roadways.

11.Never direct the discharge of material from operating reels toward bystanders nor allow anyone near the mower during operation.

12.Handle gasoline with CAUTION - it is highly flammable.

a.Use an approved gasoline container.

b.Never fill the fuel tank indoors. Wipe spilled gas immediately.

c. Open garage doors to allow ventilation if engine is run inside-exhaust fumes are dangerous. Do not run engine in any enclosed area.

13.Keep the mower in good operating condition. Make sure that all safety switches are operating properly and all safety guards are in place at all times, except during servicing.

14.Keep all nuts, bolts and screws tight to be sure that the mower is in a safe working condition.

15.Never store the mower, with gasoline in the tank, inside a building where the fumes could reach an open flame or spark. Allow the engine to cool before storing in any enclosure.

16.Keep the engine free of grass, leaves or excessive grease to reduce a fire hazard.

17.The mower and reels should be stopped and inspected for damage after striking a foreign object. The damage should be repaired before restarting and operating the mower.

18.Do not change the engine governor settings or over speed the engine.

19.Proceed as follows when mowing.

a.Mow only in the daylight or in good artificial light.

b.Never make a cutting height adjustment while the engine (motor) is running.

c.Shut the engine (motor) off when removing grass or unclogging reels.

WARNING– California, USA residents are required by law (CA PRC 4442 & CA H & SC 13005) to equip their engines with spark arresters when operating in flammable vegitation. Arresters must be obtained from your engine dealer and are not available from National Mower Company.

3

Image 3
Contents Hydro 70 Triplex Raymond Avenue, St. Paul, Minnesota 55114 U.S.A Declaration of ConformityNational Mower Safe Operation Practices For Riding Mowers Table of Contents Receipt of Shipment IntroductionSpecifications Disposal Numbers TransfersNoise Emission & Vibration Transfer Description Assembly of Rear Cutting Unit to Tractor Assembly InstructionsAssembly Tractor AssemblyAssembly of Rear Cutting UNIT, General Information DROP/LIFT Needle Valve Interlock SwitchesChoke Throttle LeverReel Control Clutch Adjustment AdjustmentsAdjustments Traction Pedal AdjustmentReel Control Clutch Seat Switch AdjustmentHeight of CUT Adjustment AdjustmentReel to Bedknife Adjustment Reel END Play AdjustmentBacklapping Procedure Backlapping Procedure Grinding ProcedureMaintenance General MaintenanceAssembly & Disassembly Fuel Filter Charging a BatteryBED Knife Replacement MaintenanceHydraulic OIL Hydraulic HosesJumper Cables Belt ReplacementHydraulic OIL Filter Handle BAR RemovalCoupling Alignment Belt ReplacementTires StorageGeneral Instructions TractorTractor will not Move Trouble Shooting GuideEngine will not Start Reel will not CUTLubrication National Hydro 70 Triplex Reel Control Ordering Information Parts ListHY70OM-8/99 Description Qty Tank and Rear Fork AssemblyHY70OM-8/99 Steering Tower Assembly HY70OM-8/99 Knob Engine and Footrest AssemblyHY70OM-8/99 Part No. Description Qty. Item Traction Pedal and Pump AssemblyHY70OM-8/99 Lift ARM and Drive Assembly HY70OM-8/99 SKIDBAR, L.H Front Cutting Unit AssemblyHY70OM-8/99 Side PLATE, L.H Center Rear Cutting Unit AssemblyPump Wheel Motor Filter Lift Hydraulic Hose and Line Assembly Pump Wheel Motor Filter Lift Tank Hydraulic Fitting Assembly Belt Tool KIT KIt No Basket Assembly Kit NoPump Part No Height of CUT BAR Kit NoLift Valve Part No Wheel Motor Part Nos , 07388Front Roller Scraper KIT Part No Lift Cylinder Part NoValve Block Part No Rear Roller Scraper KIT Part NoNational Mower Company National Mower CompanyRaymond Avenue, St. Paul, Minnesota 55414, U.S.A