Multiquip GAC3.6HZ manual Components generator

Page 18

components (generator)

Figure 4. Generator Components (Continued)

10.Spark Plug – Provides spark to the ignition system. Set spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch) Clean spark plug once a week.

11.Muffler/Heat Shield – Used to reduce noise and emissions. NEVER touch this heat shield when the generator/welder is in use. Always allow time for engine to cool before servicing.

12.Air Cleaner – Prevents dirt and other debris from entering the fuel system. Remove wing-nut on top of air filter cannister to gain access to filter element. NEVER run the engine without an air cleaner.

13.Fuel Tank Cap – Remove cap to add unleaded gasoline to the fuel tank. Replenish with clean unleaded gasoline. Make sure cap is tightened securely. DO NOT over fill.

14.Choke Lever – Used for starting the engine. Close the choke lever when starting a cold engine or in cold weather conditions. The choke enriches the fuel mixture. Open the choke lever if starting a warm engine or in warm weather conditions.

15.Fuel Cock Lever – Turn lever downward to start (down) the flow of fuel into the carburetor.Turn upward to stop (up) the flow of fuel.

16.Engine Oil Filler Cap – Remove cap/dipstick when the adding of engine oil is required. See Table 4 for recommended type engine oil.

17.Engine Oil Drain Plug – Remove drain plug when draining of the oil from the engine crankcase is required. Fill with recommeded type oil as listed in Table 4.

18.Recoil Starter (pull rope) – Manual-starting method. Pull the starter grip until resistance is felt, then pull briskly and smoothly.

19.Fuel Tank – Fuel tank capacity is 5 gallons (19 liters)

20.Fuel Gauge – This gauge is located on top of the fuel tank. Read this gauge to determine when fuel is low.

NOTICE

This HONDA engine is equipped with a low oil shutdown capability. A built in sensor will automatically turn off the engine should the oil level fall below a safe operating condition. Make sure the generators is placed on level ground. Placing the generators on level ground will ensure that the low oil sensor will function properly.

page 18 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev. #1 (03/31/10)

Page 17 Page 19
Image 18
Page 17 Page 19
Contents Model gac3.6hz Table of Contents GAC3.6HZ Portable 60 Hz GeneratorChoose from three easy options Safety Information SaFeTY messagesGeNeRal saFeTY GeNeRaTOR saFeTYENgiNe saFeTY Fuel saFeTYGrounding safety ElecTRical saFeTYPower cord/cable safety BaTTeRY saFeTY elecTRic sTaRT ONlYTRaNspORTiNg saFeTY ENviRONmeNTal saFeTYPage Specifications gENERATOR Specifications GeneratorsSpecifications engine Effects of Altitude and HeatDimensions 18.9 480 MMPage Installation Connecting the GroundPlacement Outdoor InstallationIndoor Installation Generator GroundingGeneral information GeneratorControl Box Components generator Gfci Ground Gfci ground connection pointComponents generator General Inspection Prior to Operation Ground Power Tools Extension CableMain Circuit Breaker Before Starting Engine Oil CheckFuel Check Operation Before Starting the EngineStarting the Engine Place main circuit breaker in the on position Operation/shutdown Stopping the EnginePreparation for long term storage Generators StorageMaintenance First EveryDaily MaintenanceEngine Air Cleaner WeeklyGenerator wiring diagram SW2Troubleshooting Engine TroubleshootingWeak in power Water in fuel system? Load Active LoadNo Load OutputPage Explanation of Code in Remarks Column Filter Fuel Suggested Spare PartsCAP Fuel Tank Spark PlugNameplate and decals 5561008 and belowPart Name Generator assy RECTIFIER, D3SB80 Rotor AssyField Coil Surge AbssorberControl BOX assy Control BOX Idle Control SwitchOperation Switch Slow Down UnitPipe Frame assy Base Pipe FrameBracket Rubber SuspensionMuffler assy Muffler SealTapping Screw Honda gx240k1/u1edn2 engine cylinder head assy GUIDE, EX. Valve Over Size Head COMP., CylnderGUIDE, IN. Valve Over Size CLIP, Valve GuideHonda gx240k1/u1edn2 engine cylinder barrel assy SHAFT, Governor ARM Switch ASSY., OIL LevelBarrel ASSY., Cylinder CORD, EarthHonda gx240k1/u1edn2 engine crankcase cvr. assy PIN, Governor Weight WEIGHT, GovernorHOLDER, Governor Weight PACKING, Case CoverHonda gx240k1/u1edn2 engine Crankshaft assy KEY SPECIAL, Woodruff Honda gx240k1/u1edn2 engine Piston assy Ring SET, Piston BOLT, Connecting RODRing SET, Piston STD Piston STDHonda gx240k1/u1edn2 engine cAMshaft assy ROD, Push SPRING, Weight ReturnNUT, Pivot Adjusting ARM, Valve RockerHonda gx240k1/u1edn2 engine Recoil Starter assy SPRING, Friction PULLEY, Recoil StarterRATCHET, Starter SPRING, Starter ReturnHonda gx240k1/u1edn2 engine FAN Cover assy Shroud CLIP, Wire HarnessCover COMP., FAN GROMMET, Drain HoleHonda gx240k1/u1edn2 engine caRBURETOR assy Valve SET, Float PACKING, AIR CleanerGasket SET Float SETHonda gx240k1/u1edn2 engine caRBURETOR assy GUIDE, Choke ROD ROD, Choke ControlGROMMET, Choke ROD VALVE, Dashpot CheckHonda gx240k1/u1edn2 engine AIR Cleaner assy Case COMP., AIR Cleaner ELEMENT, AIR CleanerSEPARATOR, AIR Cleaner STAY, AIR CleanerHonda gx240k1/u1edn2 engine Flywheel assy Flywheel Comp FAN, CoolingPULLEY, Starter NUT, SPECIAL, 16MMHonda gx240k1/u1edn2 engine Ignition Coil assy Coil ASSY., Ignition HOLDER, Stop Switch CordCORD, Stop Switch CAP ASSY., Noise SuppressonHonda gx240k1/u1edn2 engine GOV. Control assy ROD, Governor SPRING, Control AdjustingARM, Governor SPRING, GovernorHonda gx240k1/u1edn2 engine Auto Throttle assy STAY, Solenoid Throttle CAP, Choke LeverSPRING, Choke Return Solenoid AssyHonda gx240k1/u1edn2 engine Fuel Cock assy Filter CUP PACKING, Fuel Strainer CUPRing CUP, Fuel StrainerHonda gx240k1/u1edn2 engine Decal assy DECAL, AIR Cleaner DECAL, ChokeMARK, OIL Caution Honda gx240k1/u1edn2 engine Tool KIT Sapnner Wrench COMP. Spark PlugHANDLE, BOX Wrench BAG ToolTerms and Conditions of Sale Parts FReighT pOlicYPage HERE’S HOW to GET Help

GAC3.6HZ specifications

The Multiquip GAC3.6HZ is a highly efficient air-cooled generator designed to meet the energy demands of both residential and industrial applications. This generator showcases a perfect combination of performance, durability, and ease of use, making it a popular choice among contractors, event organizers, and homeowners alike.

One of the standout features of the GAC3.6HZ is its powerful Honda GX160 engine, known for its reliability and fuel efficiency. The engine delivers an impressive output of 3.6 kilowatts, making it suitable for a wide range of applications from powering tools on job sites to supplying electricity for small events. The generator's maximum power output ensures that it can handle heavy loads while maintaining consistent performance.

Equipped with a large-capacity fuel tank, the GAC3.6HZ provides extended operation without the need for frequent refueling. This makes it ideal for situations where access to fuel may be limited, such as remote job sites. Additionally, the generator features a low oil shutdown system that enhances engine longevity by automatically shutting down the engine in the event of low oil levels, protecting it from damage.

The GAC3.6HZ is designed with portability in mind. It includes a robust frame, built-in wheels, and a convenient lifting handle, allowing for easy transportation between locations. Its compact design also ensures that it can be stored in smaller spaces without hassle.

Another significant aspect of the GAC3.6HZ is its user-friendly control panel, which features clearly labeled outlets, including multiple 120V AC outlets and a 12V DC outlet for battery charging. The intuitive layout of the control panel simplifies operation, even for users who may not be familiar with generator functions.

Multiquip has incorporated advanced noise reduction technologies into the GAC3.6HZ, ensuring that it operates at lower noise levels compared to traditional generators. This is particularly beneficial for noise-sensitive environments, where quiet operation is essential.

In summary, the Multiquip GAC3.6HZ stands out as an exceptional generator owing to its robust Honda engine, fuel efficiency, extended run time, user-friendly design, and advanced noise-reduction features. Whether for commercial use or home backup, this generator provides reliable power when it is most needed, all within a compact and portable format.
Top Page Image Contents