Multiquip GA6HZR manual GA-6HZR Installation

Page 11

Outdoor Installation

Install the generator in a location where it will not be exposed to rain or sunshine. Make sure that the generator is on secure level ground so that it cannot slide or shift around. Also install the generator in a manner so that the exhaust will not be discharged in the direction of nearby homes.

The installation site must be relatively free from moisture and dust. All electrical equipment should be protected from excessive moisture.Failure to do will result in deterioration of the insulation and will result in short circuits and grounding.

Foreign materials such as dust, sand, lint and abrasive materials have a tendency to cause excessive wear, not only to the engine parts, but also to the alternator parts.

GA-6HZR — INSTALLATION

Indoor Installation

Exhaust gases from gasoline engines are extremely poisonous. Whenever an engine is installed indoors the exhaust fumes must be vented to the outside. The engine should be installed at least two feet from any outside wall. Using an exhaust pipe which is too long or too small can cause excessive back pressure which will cause the engine to heat excessively and possibly burn the valves.

Eliminate the danger of deadly carbon monoxide gas. Remember that exhaust fumes from any gasoline engine are very poisonous if discharged in a closed room, but harmless if allowed to mix with the outside air.If the generator is installed indoors, you must make provisions for venting the engine exhaust to the outside of the building.

CAUTION :CAUTION :

Pay close attention to ventilation when operating the generator inside confined areas. The engine exhaust contains noxious elements.

An electric shock is apt to happen when vibrators are used. Pay close attention to handling when operating vibrators and always use rubber boots and gloves to insulate the body from a short circuit.

GA-6HZR A.C. GENERATOR — OPERATION AND PARTS MANUAL — REV. #3 (03/30/11) — PAGE 11

Page 10 Page 12
Image 11
Page 10 Page 12
Contents Model GA6HZR Proposition 65WARNING Page Table of Contents Ordering parts has never been easier Parts Ordering ProceduresRules for Safe Operation General SafetyOperation and Safety Decals Page GA-6HZR Familiarization GA-6HZR General InformationGA-6HZR Controls and Indicators GA-6HZR Installation General Inspection Prior to Operation GA-6HZR PRE-SETUPFuel Main Circuit Breaker 2-Pole 120/240V 60 Hz GA-6HZR InstrumentationGA-6HZR Load Application GA-6HZR Operating Instructions GA-6HZR Maintenance Generator Storage GA-6HZR Preparation for Long -TERM StorageGA-6HZR -WIRING Diagram GA-6HZR -TROUBLESHOOTING Engine GA-6HZR -TROUBLESHOOTING Engine GA-6HZR -TROUBLESHOOTING Generator GA-6HZR -TROUBLESHOOTING Generator GA-6HZR Explanation of Code in Remarks Column To 5 Units GA-6HZR Suggested Spare PartsGA-6HZR Generator Assy Surge Absorber Rotor ASS’YField Coil RectifierGA-6HZR Control BOX Assy Control BOX GA-6HZR Control BOX AssyGA-6HZR Pipe Frame Assy Rubber Suspension Pipe FrameBracket BaseGA-6HZR Muffler Assy Muffler GA-6HZR Muffler AssyGA-6HZR- Nameplate Assy Decal Danger Decal MQ GA-6HZRDecal Caution Decal WarningHonda GX340K1EDN2 Engine Cylinder Head PACKING, Head Cover GUIDE, IN. Valve Over SizeCLIP, Valve Guide Cover COMP., HeadHonda GX340K1EDN2 Engine Recoil Starter SPRING, Starter Return PULLEY, Recoil StarterRATCHET, Starter SPRING, FrictionHonda GX340K1EDN2 Engine FAN Cover Clip Cover COMP., FANShroud Honda GX340K1EDN2 Engine CAMSHAFT/VALVES ARM, Valve Rocker SPRING, Weight ReturnNUT, Pivot Adjusting ROD, PushHonda GX340K1EDN2 Engine PISTON/RINGS PIN, Piston Ring SET, Piston STDRing SET, Piston Piston STDHonda GX340K1EDN2 Engine AIR Cleaner Tube Breather ELEMENT, AIR CleanerSTAY, AIR Cleaner SEAL, AIR CleanerCylinder Barrel ASSY. Recoil Starter Honda GX340K1EDN2 Engine Cylinder BarrelBOLT, Drain Plug Switch ASSY., OIL LevelBarrel ASSY., Cylinder SHAFT, Governor ARMCylinder Barrel ASSY. Electric Start 12000ZE3826 Honda GX340K1EDN2 Engine Crankcase COVER/GOVERNOR PACKING, Case Cover Honda GX340K1EDN2 Engine FLYWHEEL/FAN Assy NUT, SPECIAL, 16 MM FAN, CoolingPULLEY, Starter Flywheel CompHonda GX340K1EDN2 Engine Coil Assy Coil ASSY., Lamp 12V/25W CLAMP, WireCORD, Stop Switch Coil ASSY., IgnitionHonda GX340K1EDN2 Engine Crankshaft Assy GEAR, Timing WEIGHT, BalancerGEAR, Balancer Drive Honda GX340K1EDN2 Engine Governor Controls Assy Honda GX340K1EDN2 Engine Governor Controls Assy Honda GX340K1EDN2 Engine Carburetor Assy Valve SET, Float PACKING, AIR CleanerCLIP, Wire Harness Gasket SETHonda GX340K1EDN2 Engine Solenoid Assy Solenoid Assy Honda GX340K1EDN2 Engine Fuel Cock Assy CUP, Fuel Strainer SCREEN, Fuel StrainerRing Filter CUPTerms and Conditions of Sale Parts Page HERE’S HOW to GET Help

GA6HZR specifications

The Multiquip GA6HZR is a versatile and robust diesel generator, designed to deliver reliable power in a variety of settings including construction sites, events, and emergency backup scenarios. It is particularly noted for its innovative engineering and high-performance capabilities, making it a preferred choice among professionals in need of dependable power solutions.

One of the key features of the GA6HZR is its powerful engine, which typically consists of a four-cylinder diesel engine that provides substantial output while maintaining fuel efficiency. This engine is engineered to produce an output of up to 6,000 watts, making it suitable for a variety of equipment and applications. The generator is also equipped with an automatic voltage regulator (AVR), ensuring a steady and consistent voltage supply, which is critical for sensitive electronic equipment.

Safety and durability are paramount in the design of the GA6HZR. The generator features a heavy-duty, weather-resistant enclosure that protects it from the elements, thereby enhancing its longevity. Additionally, it is designed to minimize noise levels, adhering to regulations for sound pollution without compromising performance. The built-in fuel tank has a large capacity, enabling extended run times between refueling, which is particularly advantageous for long-term operations.

Another significant characteristic of the Multiquip GA6HZR is its portability. The generator comes with rugged wheels and handles, making it easy to transport across job sites or between different locations. This level of mobility ensures that users can quickly deploy power wherever it is needed most.

In terms of technology, the GA6HZR incorporates advanced features such as hour meters and control panels that provide real-time information about the generator’s performance and operational status. This enhances user convenience and allows for proactive maintenance planning, ensuring that the generator operates efficiently for a longer duration.

Overall, the Multiquip GA6HZR stands out due to its powerful performance, robust construction, and user-friendly design. It is an excellent solution for those seeking a reliable, high-capacity generator that can handle demanding power needs across various applications. Whether for professional or emergency use, the GA6HZR remains a trusted choice in the generator market.
Top Page Image Contents