Multiquip GA-2.5H manual Fuel Gauge Read this gauge to determine when fuel is low

Page 17

GA-2.5H — CONTROLS AND INDICATORS

Figure 2B. Generator Components

8. Generator Housing – Contains the rotor, rectifer field coil assembly, aramature, bearings and other components that make up generator asembly.

9. Spark Plug – Provides spark to the ignition system. Set spark plug gap to 0.6 - 0.7 mm (0.024 - 0.028 inch). Clean spark plug once a week.

10. Muffler/Heat Shield – Used to reduce noise and emissions. NEVER touch this heat shield when the generator is in use. Always allow time for the generator to cool down before performing maintenance.

11. Oil Dipstick/ Filler Cap– Remove the filler cap dipstick when checking the engine oil level. Add engine oil through

12. Oil Drain Plug – Remove this plug to drain engine oil from the crankcase.

13. Carburetor Fuel Cup – Inspect the fuel cup weekly for water and dirt. Clean as referenced in the maintenance section of this manual.

14. Choke Lever – Used for starting the engine. Close the choke lever when starting a cold engine or in cold weather conditions. The choke enriches the fuel mixture. Open the choke lever if starting a warm engine or in warm weather conditions.

15. Fuel Cock Lever – Turn this lever downward to start (down)the flow of fuel to the carburetor. Turn upward to stop (up) the flow of fuel.

16. Throttle Lever – Used to adjust engine RPM speed. This unit is set at the factory and is not adjustable.

17. Recoil Starter (Pull Rope) – Used for manual-starting of the engine. Pull the starter grip until resistance is felt, then pull briskly and smoothly.

18. Engine – This generator uses a 5.5 HP HONDA air- cooled, 4-stroke , single cylinder, overhead camshaft gasoline engine. Engine uses unleaded gasoline.

19. Air Cleaner – Every 50 hours: Prevents dirt and other debris from entering the fuel system. Remove wing-nut on top of air filter cannister to gain access to filter element. NEVER run the engine without an air cleaner.

20. Fuel Gauge – Read this gauge to determine when fuel is low.

21. Fuel Gauge/Tank – Remove this cap to add unleaded gasoline to the fuel tank. Replenish with clean unleaded gasoline. Make sure cap is tightened securely. DO NOT over fill. Fuel tank capacity is 3.2 gallons (12 liters).

GA-2.5H A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #5 (03/04/08) — PAGE 17

Image 17
Contents Model GA-2.5H Page Page Table of Contents Order via Fax Dealers Only Parts Ordering ProceduresBest Deal! Order via Internet Dealers Only Respiratory Hazards GA-2.5H Safety Message Alert SymbolsBurn Hazards Rotating Parts Hazards GA-2.5H Safety Message Alert SymbolsEquipment Damage Read this manual GA-3.6H- Rules for Safe OperationGA-2.5H Rules for Safe Operation Power Cord SafetyEmergencies GA-2.5H Rules for Safe OperationDry Net Weight Dimensions ApproximateWeight With Fuel W x HModel GA-2.5H Specifications EngineDimension L x W x H Dimensions GA-2.5H DimensionsGA-2.5H General Information GA-2.5H Load Application Single Phase Load 60 HzIncandescent Loads Small MotorsGenerator Components GA-2.5H Controls and IndicatorsFuel Gauge Read this gauge to determine when fuel is low Generator Refueling MQ GA-2.5H Generator RefuelingOutdoor Installation GA-2.5H InstallationIndoor Installation MountingConnecting the Ground GA-2.5H InstallationGA-2.5H PRE-INSPECTION General Inspection Prior to Operation Ground Power ToolsExtension Cable Main Circuit BreakerBefore Starting GA-2.5H PRE-INSPECTION EngineEngine Oil Check Fuel CheckBefore Starting the Engine GA-2.5H Initial START-UP EngineStopping The Engine GA-2.5H Initial START-UP ENGINE/OPERATIONGenerator Storage MQ GA-2.5H Preparation for Long -TERM StorageEngine Maintenance Schedule MQ GA-2.5H Maintenance EngineMaintenance MQ GA-2.5H Maintenance EngineCleaning the Fuel Strainer Generator/Engine Wiring Diagram S/N 5496762 and below GA-2.5H Wiring Diagram S/N 5496762 and belowGenerator/Engine Wiring Diagram S/N 5496763 and above GA-2.5H Wiring Diagram S/N 5496763 and AboveEngine Troubleshooting GA-2.5H Troubleshooting EngineWhite GA-2.5H Troubleshooting EngineGenerator Troubleshooting GA-2.5H Troubleshooting GeneratorPage NO. Column GA-2.5H Explanation of Code in Remarks ColumnPart NO. Column QTY. ColumnTo 5 Units GA-2.5H Suggested Spare PartsGA-2.5H Nameplate and Decals Machine Safety DecalsName Plate Assy Decal AIR CleanerGA-2.5H Nameplate and Decals Generator Assy MQ GA-2.5H Generator AssySET WASHER, Bearing SET BOLT, RotorSpring Washer END Bracket C SideControl BOX ASSY. S/N 5496762 and below MQ GA-2.5H Control BOX ASSY. S/N 5496762 and belowMachine Screw Control BOXControl Panel HEX. NUTControl BOX ASSY. S/N 5496763 and Above MQ GA-2.5H Control BOX ASSY. S/N 5496763 and AboveBRACKET, Circuit Breaker Pipe Frame ASSY. S/N 5496762 and below MQ GA-2.5H Pipe Frame ASSY. S/N 5496762 and belowWasher Pipe FrameRubber Suspension Fuel TankPipe Frame ASSY. S/N 5496763 and Above MQ GA-2.5H Pipe Frame ASSY. S/N 5496763 and AboveFilter N/C CUP, Fuel StrainerHose Rubber CushionCylinder Head Assy Honda GX160K1EMA2 Engine Cylinder Head AssyCLIP, Valve Guide GUIDE, IN. ValveGASKET, Cylinder Head Cover COMP, HeadCylinder Barrel Assy Honda GX160K1EMA2 Engine Cylinder Barrel AssyHOLDER, Govenor Weight Switch ASSY, OIL LevelPIN, Governor Weight SLIDER, GovernorCrankcase Cover Assy Honda GX160K1EMA2 Engine Crankcase Cover AssyCAP, OIL Filler GASKET, Case CoverGASKET, OIL Filler CAP BOLT, LangeCrankshaft Assy Honda GX160K1EMA2 Engine Crankshaft AssyCrankshaft VE-TYPE Part Name QTY. RemarksPiston Assy Honda GX160K1EMA2 Engine Piston AssyBOLT, Connecting ROD ROD ASSY, ConnectingRing SET, Piston STD Ring SET, PistonCamshaft Assy Honda GX160K1EMA2 Engine Camshaft AssyNUT, Pivot Adjusting SPRING, Weight ReturnROD, Push ARM, Valve RockerRecoil Starter Assy Honda GX160K1EMA2 Engine Recoil Starter AssyREEL, Recoil Starter SCREW, SettingRATCHET, Starter GUIDE, RatchetFAN Cover Assy Honda GX160K1EMA2 Engine FAN Cover AssyShroud COMP., Lower COVER, FAN NH1 BlackIncludes Items W Shroud ASSY., UpperCarburetor Assy Honda GX160K1EMA2 Engine Carburetor AssyGasket SET GASKET, AIR CleanerValve SET, Float Float SETAIR Cleaner Assy Honda GX160K1EMA2 Engine AIR Cleaner AssyCover AIR Cleaner ELEMENT, AIR CleanerStay AIR Cleaner SEAL, AIR CleanerMuffler Assy Honda GX160K1EMA2 Engine Muffler AssyPipe COMP., EX Muffler CompARRESTER, Spark GASKET, MufflerHonda GX160K1EMA2 Engine Flywheel Assy Honda GX160K1EMA2 Engine Flywheel Assy Ignition Coil Assy Honda GX160K1EMA2 Engine Ignition Coil AssyGROMMET, Wire CLAMP, WireWIRE, Stop Switch Coil ASSY., IgnitionGOVERNOR/CONTROL Assy Honda GX160K1EMA2 Engine GOVERNOR/CONTROL AssySPRING, Throttle Return ROD, GovernorBOLT, Governor ARM NUT, FLANGE, 6MMHonda GX160K1EMA2 Engine Labels Assy Honda GX160K1EMA2 Engine Labels Assy DECAL, AIR CleanerEMBLEM, 5.5 HP DECAL, ChokeFreight Policy Terms and Conditions of Sale PartsPage HERE’S HOW to GET Help

GA-2.5H specifications

The Multiquip GA-2.5H is a robust, portable generator designed to meet the demands of both commercial and residential users. Renowned for its reliability and efficiency, it is an ideal choice for construction sites, outdoor events, and emergency power needs. With a compact design, the GA-2.5H is easy to transport, making it a convenient option for those who require power on-the-go.

One of the standout features of the GA-2.5H is its powerful Honda GX160 engine. This four-stroke engine offers a consistent and robust performance, ensuring that the generator can handle various loads without faltering. The engine is also known for its fuel efficiency, allowing users to prolong operational periods and minimize running costs.

The generator provides a maximum output of 2,500 watts, making it suitable for powering essential tools and equipment. Equipped with multiple outlets, including both 120V and 240V options, the GA-2.5H can accommodate various appliances and devices, making it a versatile solution for different power needs.

In terms of durability, the GA-2.5H is built with high-quality materials that can withstand harsh environments. Its heavy-duty frame not only protects the generator components but also ensures stability during operation. Additionally, the unit features a protective circuit breaker that enhances safety by preventing overloads.

Another notable characteristic is its quiet operation. The GA-2.5H is engineered with noise-reduction technologies that significantly lower the sound output, making it ideal for use in noise-sensitive areas. This feature allows users to maintain a peaceful atmosphere, whether at a campsite or a residential neighborhood.

The Multiquip GA-2.5H also incorporates a user-friendly control panel, making it easy for anyone to operate. The panel includes clearly labeled controls and indicators, allowing users to monitor fuel levels, voltage output, and other critical parameters at a glance.

For added convenience, the GA-2.5H comes with a built-in fuel tank that provides extended run times. This larger tank ensures that users can operate the generator for longer periods without the need for frequent refueling.

Overall, the Multiquip GA-2.5H stands out as a powerful, efficient, and portable generator, suitable for a wide range of applications. With its excellent features, durable build, and quiet operation, it is an exceptional choice for anyone in need of reliable power solutions. Whether for construction, emergency backup, or outdoor events, the GA-2.5H delivers performance that users can depend on.