Multiquip manual GA-2.5H PRE-INSPECTION Engine, Before Starting, Engine Oil Check, Fuel Check

Page 22

GA-2.5H — PRE-INSPECTION (ENGINE)

CAUTION

NEVER operate the generator in a confined area or enclosed area structure that does not provide ample free flow of air.

ALWAYS wear approved eye and hearing protection before operating the generator.

Before Starting

1.Read safety instructions at the beginning of manual.

2.Clean the generator, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner.

3.Check the air filter for dirt and dust. If air filter is dirty, replace air filter with a new one as required.

4.Check carburetor for external dirt and dust. Clean with dry compressed air.

5.Check fastening nuts and bolts for tightness.

Engine Oil Check

1.To check the engine oil level, place the generator on secure level ground with the engine stopped.

2.Remove the filler dipstick from the engine oil filler hole (Figure 6) and wipe clean.

Figure 7. Engine Oil Dipstick (Oil Level)

Table 5. Oil Type

Season

Temperature

Oil Type

 

 

 

Summer

25°C or Higher

SAE 10W-30

 

 

 

Spring/Fall

25°C~10°C

SAE 10W-30/20

 

 

 

Winter

0°C or Lower

SAE 10W-10

 

 

 

DANGER EXPLOSIVE FUEL

Motor fuels are highly flammable and can be dangerous if mishandled.DO NOT smoke while refueling. DO NOT attempt to refuel the generator if the engine is hot! , running or in the dark.

Fuel Check

1.Close the fuel cock before filling the fuel tank.

2.Remove the fuel cap located on top of fuel tank.

3.Read the fuel gauge located on top of the fuel tank (Figure 8) to determin if the fuel level is low. If fuel is low, replenish with clean unleaded fuel.

Figure 8. Fuel Gauge

Figure 6. Engine Oil Dipstick (Removal)

3.Insert and remove the dipstick without screwing it into the filler neck. Check the oil level shown on the dipstick.

4.If the oil level is low (Figure 7), fill to the edge of the oil filler hole with the recommended oil type (Table 5).Maximum oil capacity is .63 quarts (0.6 liters)

4.When refueling, be sure to use a strainer for filtration. DO NOT top-off fuel. DO NOT fill the tank beyond capacity. Wipe up any spilled fuel immediately!

PAGE 22 — GA-2.5H A.C. GENERATOR — OPERATION & PARTS MANUAL — REV. #5 (03/04/08)

Page 21 Page 23
Image 22
Page 21 Page 23
Contents Model GA-2.5H Page Page Table of Contents Best Deal! Order via Internet Dealers Only Parts Ordering ProceduresOrder via Fax Dealers Only Burn Hazards GA-2.5H Safety Message Alert SymbolsRespiratory Hazards Equipment Damage GA-2.5H Safety Message Alert SymbolsRotating Parts Hazards GA-3.6H- Rules for Safe Operation Read this manualPower Cord Safety GA-2.5H Rules for Safe OperationGA-2.5H Rules for Safe Operation EmergenciesWeight With Fuel Dimensions ApproximateDry Net Weight W x HDimension L x W x H GA-2.5H Specifications EngineModel GA-2.5H Dimensions DimensionsGA-2.5H General Information Incandescent Loads Single Phase Load 60 HzGA-2.5H Load Application Small MotorsGA-2.5H Controls and Indicators Generator ComponentsFuel Gauge Read this gauge to determine when fuel is low MQ GA-2.5H Generator Refueling Generator RefuelingIndoor Installation GA-2.5H InstallationOutdoor Installation MountingGA-2.5H Installation Connecting the GroundExtension Cable General Inspection Prior to Operation Ground Power ToolsGA-2.5H PRE-INSPECTION Main Circuit BreakerEngine Oil Check GA-2.5H PRE-INSPECTION EngineBefore Starting Fuel CheckGA-2.5H Initial START-UP Engine Before Starting the EngineGA-2.5H Initial START-UP ENGINE/OPERATION Stopping The EngineMQ GA-2.5H Preparation for Long -TERM Storage Generator StorageMQ GA-2.5H Maintenance Engine Engine Maintenance ScheduleCleaning the Fuel Strainer MQ GA-2.5H Maintenance EngineMaintenance GA-2.5H Wiring Diagram S/N 5496762 and below Generator/Engine Wiring Diagram S/N 5496762 and belowGA-2.5H Wiring Diagram S/N 5496763 and Above Generator/Engine Wiring Diagram S/N 5496763 and aboveGA-2.5H Troubleshooting Engine Engine TroubleshootingGA-2.5H Troubleshooting Engine WhiteGA-2.5H Troubleshooting Generator Generator TroubleshootingPage Part NO. Column GA-2.5H Explanation of Code in Remarks ColumnNO. Column QTY. ColumnGA-2.5H Suggested Spare Parts To 5 UnitsMachine Safety Decals GA-2.5H Nameplate and DecalsGA-2.5H Nameplate and Decals Decal AIR CleanerName Plate Assy MQ GA-2.5H Generator Assy Generator AssySpring Washer SET BOLT, RotorSET WASHER, Bearing END Bracket C SideMQ GA-2.5H Control BOX ASSY. S/N 5496762 and below Control BOX ASSY. S/N 5496762 and belowControl Panel Control BOXMachine Screw HEX. NUTMQ GA-2.5H Control BOX ASSY. S/N 5496763 and Above Control BOX ASSY. S/N 5496763 and AboveBRACKET, Circuit Breaker MQ GA-2.5H Pipe Frame ASSY. S/N 5496762 and below Pipe Frame ASSY. S/N 5496762 and belowRubber Suspension Pipe FrameWasher Fuel TankMQ GA-2.5H Pipe Frame ASSY. S/N 5496763 and Above Pipe Frame ASSY. S/N 5496763 and AboveHose CUP, Fuel StrainerFilter N/C Rubber CushionHonda GX160K1EMA2 Engine Cylinder Head Assy Cylinder Head AssyGASKET, Cylinder Head GUIDE, IN. ValveCLIP, Valve Guide Cover COMP, HeadHonda GX160K1EMA2 Engine Cylinder Barrel Assy Cylinder Barrel AssyPIN, Governor Weight Switch ASSY, OIL LevelHOLDER, Govenor Weight SLIDER, GovernorHonda GX160K1EMA2 Engine Crankcase Cover Assy Crankcase Cover AssyGASKET, OIL Filler CAP GASKET, Case CoverCAP, OIL Filler BOLT, LangeHonda GX160K1EMA2 Engine Crankshaft Assy Crankshaft AssyPart Name QTY. Remarks Crankshaft VE-TYPEHonda GX160K1EMA2 Engine Piston Assy Piston AssyRing SET, Piston STD ROD ASSY, ConnectingBOLT, Connecting ROD Ring SET, PistonHonda GX160K1EMA2 Engine Camshaft Assy Camshaft AssyROD, Push SPRING, Weight ReturnNUT, Pivot Adjusting ARM, Valve RockerHonda GX160K1EMA2 Engine Recoil Starter Assy Recoil Starter AssyRATCHET, Starter SCREW, SettingREEL, Recoil Starter GUIDE, RatchetHonda GX160K1EMA2 Engine FAN Cover Assy FAN Cover AssyIncludes Items W COVER, FAN NH1 BlackShroud COMP., Lower Shroud ASSY., UpperHonda GX160K1EMA2 Engine Carburetor Assy Carburetor AssyValve SET, Float GASKET, AIR CleanerGasket SET Float SETHonda GX160K1EMA2 Engine AIR Cleaner Assy AIR Cleaner AssyStay AIR Cleaner ELEMENT, AIR CleanerCover AIR Cleaner SEAL, AIR CleanerHonda GX160K1EMA2 Engine Muffler Assy Muffler AssyARRESTER, Spark Muffler CompPipe COMP., EX GASKET, MufflerHonda GX160K1EMA2 Engine Flywheel Assy Honda GX160K1EMA2 Engine Flywheel Assy Honda GX160K1EMA2 Engine Ignition Coil Assy Ignition Coil AssyWIRE, Stop Switch CLAMP, WireGROMMET, Wire Coil ASSY., IgnitionHonda GX160K1EMA2 Engine GOVERNOR/CONTROL Assy GOVERNOR/CONTROL AssyBOLT, Governor ARM ROD, GovernorSPRING, Throttle Return NUT, FLANGE, 6MMHonda GX160K1EMA2 Engine Labels Assy EMBLEM, 5.5 HP DECAL, AIR CleanerHonda GX160K1EMA2 Engine Labels Assy DECAL, ChokeTerms and Conditions of Sale Parts Freight PolicyPage HERE’S HOW to GET Help

GA-2.5H specifications

The Multiquip GA-2.5H is a robust, portable generator designed to meet the demands of both commercial and residential users. Renowned for its reliability and efficiency, it is an ideal choice for construction sites, outdoor events, and emergency power needs. With a compact design, the GA-2.5H is easy to transport, making it a convenient option for those who require power on-the-go.

One of the standout features of the GA-2.5H is its powerful Honda GX160 engine. This four-stroke engine offers a consistent and robust performance, ensuring that the generator can handle various loads without faltering. The engine is also known for its fuel efficiency, allowing users to prolong operational periods and minimize running costs.

The generator provides a maximum output of 2,500 watts, making it suitable for powering essential tools and equipment. Equipped with multiple outlets, including both 120V and 240V options, the GA-2.5H can accommodate various appliances and devices, making it a versatile solution for different power needs.

In terms of durability, the GA-2.5H is built with high-quality materials that can withstand harsh environments. Its heavy-duty frame not only protects the generator components but also ensures stability during operation. Additionally, the unit features a protective circuit breaker that enhances safety by preventing overloads.

Another notable characteristic is its quiet operation. The GA-2.5H is engineered with noise-reduction technologies that significantly lower the sound output, making it ideal for use in noise-sensitive areas. This feature allows users to maintain a peaceful atmosphere, whether at a campsite or a residential neighborhood.

The Multiquip GA-2.5H also incorporates a user-friendly control panel, making it easy for anyone to operate. The panel includes clearly labeled controls and indicators, allowing users to monitor fuel levels, voltage output, and other critical parameters at a glance.

For added convenience, the GA-2.5H comes with a built-in fuel tank that provides extended run times. This larger tank ensures that users can operate the generator for longer periods without the need for frequent refueling.

Overall, the Multiquip GA-2.5H stands out as a powerful, efficient, and portable generator, suitable for a wide range of applications. With its excellent features, durable build, and quiet operation, it is an exceptional choice for anyone in need of reliable power solutions. Whether for construction, emergency backup, or outdoor events, the GA-2.5H delivers performance that users can depend on.
Top Page Image Contents