Dixon ZTR 5423 manual General Operation

Page 6

This cutting mower is capable of amputating hands and feet, and throwing objects.

Failure to observe the following safety instructions could result in

serious injury or death.

GENERAL OPERATION:

Read, understand, and follow all instructions in the manual and on the mower before starting.

Only allow responsible adults, who are familiar with the instructions, to operate the mower.

Clear the area of objects such as rocks, toys, wire, etc., which could be picked up and thrown by the blade.

Be sure the area is clear of other people before mowing. Stop mower if anyone enters the area.

Never carry passengers.

Do not mow in reverse unless absolutely necessary. Always look down and behind before and while backing.

Be aware of the mower discharge direction and do not point it at anyone. Do not operate the mower without either the entire grass catcher or the deflector in place.

Slow down before turning.

Never leave a running mower unattended. Always turn off blades, set parking brake, stop engine, and remove key before dismounting.

Turn off blades when not mowing.

Stop engine before removing grass catcher or unclogging chute.

Mow only in daylight or good artificial light.

Do not operate the mower while under the influence of alcohol or drugs.

Watch for traffic when operating near or crossing roadways.

Use extra care when loading or unloading the mower into a trailer or truck. Do not ride the mower when loading & unloading.

The Engine Exhaust from this product contains chemicals known to the

State of California to cause cancer, birth defects or other reproductive harm.

Page 3

Image 6
Contents Page Important Read Carefully Index Most common causes of injury to the operator or bystander Blade Contact RUN-OVER TIP-OVERSafety Symbols Safety Alert SymbolGeneral Operation Do not Children Service Dixon Limited Warranty POLICY-- HYDRO-GEAR Models Specifications Model ZTR Chassis Seat Adjustment Instructions Controls Parking Brake To SET Parking BrakeHYDRO-GEAR Drive System Turning To GO ForwardTo GO Backward BrakingBlade Drive Circuit BreakerMower Deck CUT Height Lift Lever Operation Instructions Testing of Safety Interlock Systems Starting Instructions Cold Engine Starting Instructions Engine has been operated Mowing with a Mulching Attachment Mowing with a Grass Catcher Attachment Maintain Sharp Blades Throughout The Cutting SeasonSide Discharge of the Clippings Grass Height SuggestionsDeck Rollers Maintenance Schedule OFF-SEASON Battery StorageCutter Blade Maintenance Belt Tension Engine to Mower Deck Belt Mower Deck Serpentine BeltFuel Shut OFF Valve LubricationSeries Rear Wheels Wheel ReversalChanging the Engine OIL OIL FillProtect Your Investment Mower Deck Installation Mower Deck Leveling Procedure BOX to Hydrostat Belt Adjustment Parking Brake Cable Adjustment Neutraladjustment Forward Travel Speed Adjustments Procedure for Electric Clutch Adjustment Ohms TestHydrostatic Transmission OIL and Filter Service Electrical Systems Standard Service Parts List Standard Service Parts List Kohler AIR and OIL Filter Part NumbersSituation Causes Remedy Mower CUT QualitySide or the other Drive System Situation Causes RemedyElectrical System Situation Causes RemedyPage Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Page Owner Information Page Page Page September