Husqvarna 968999505, 968999514, 968999291, 968999513, 968999292, 968999504 Deck belt installation

Page 48

MAINTENANCE

Deck belt installation

NOTE: For ease in installing the deck belt, refer to the routing decal on the front edge of the deck.

•Wrap the deck belt around the electric clutch that is located on the engine shaft.

•Push the rest of the belt through the IZT(Integraded Zeroturn Transaxle) support and up onto the deck.

•Starting on the right hand side of the deck, wrap the belt around the large right side idler, right cutter housing pulley, small center idler, center pulley, left side pulley and then around the large left side idler.

•The belt will be loose at this point.

•Using a ratchet with a 9/16” socket on the spring idler bolt to relieve the tension on the belt. See decal on the top of deck for belt routing information.

•After installation is complete check the belt for twists.

1

2

4

3

4

1.Clutch pulley

2.Deck belt

3. Spring idler pulley

4. Fixed idler pulley Belt routing, deck belt

8011-622

Slackening the belt tensioner

English-46

Image 48

Contents Operators manual Page Contents OPERATOR’S ManualEnglish-2 Introduction IntroductionGood Service Manufacturing NumberSymbols and Decals Symbols and DecalsXxxxxxx xxxx xxxxxxxx xxx Xxxx xxxxxx Greater Than Careful Safety Instructions Safety InstructionsGeneral Operation English-8 Personal Safety Equipment Slope OperationChildren Maintenance General Maintenance Risk of sparking Transport Customer responsibilities Controls ControlsParking Brake Motion Control LeversSeat adjustment bolts TrackingFuel Shut Off Valve Refueling By pass linkage FusesIgnition Switch Hour MeterChoke Control Blade switch Throttle ControlAccessories Cutting height pedalOperation OperationTraining Before Starting Starting the EngineDepress the control for disengaging the mower deck Set the choke control USE Full Throttle When Mowing To start an engine with a weak battery To remove cables, reverse orderMower deck’s anti-scalp rollers should be evenly adjusted RunningOperating on hills Mowing Tips Stopping the Engine Moving by Hand Maintenance MaintenanceMaintenance Schedule Nance Once Each Maintenance Before After 100 Battery To clean battery and terminalsReplacing battery Always use protective glasses when handling the batteryIgnition System Checking the Safety System Checking and Adjusting Throttle Cable Checking and Adjusting the Choke CableChecking the Engines Cooling Air Intake Replacing the Air Filter Kawasaki Engine Replacing the Air Filter Briggs & Stratton Engine Standard air filterReplacing Heavy Duty Air Filter Replacing the Fuel Filter Checking the Fuel Pump’s Air FilterChecking Tire Pressures Checking the Parking Brake Checking the V-beltsDeck belt To replace deck beltDeck belt installation Belt installation IZT beltTo replace IZT Integraded Zeroturn Transaxle belt IZT belt removalChecking the Blades Remove blade bolt by turning counterclockwise Adjusting the Mower Deck Adjusting Cutting HeightLeveling To adjust anti-scalp rollers Cleaning and Washing Use protective glasses when cleaning and washingRemoval and installation of caster wheel Caster WheelsTracking adjustment To adjust parking brakeMower is tracking to the right Mower is tracking to the leftLubrication LubricationLubrication Schedule Change transaxles transmission filtersLubricating the Cables Lubricating in Accordance with the Lubrication ScheduleFront Wheel Mount Front Wheel BearingsDeck outer spindle Engine Oil Changing the Engine OilChecking the Oil Level Changing the Engine Oil Filter Transaxle Transmission Fluid ChangeExpansion Tank Purging Procedures Trouble Shooting Guide Trouble Shooting GuideProblem Cause Wrong fuel type English-63 Service StorageStorage Winter StorageWiring Diagrams Wiring diagramTechnical Data Technical DataEZ4217/968999291 EZ5221/968999292 Productivity EZ4819/968999504 EZ4824/968999513 KAI ELS605 lbs EZ5426/968999514 EZ6124/968999505 625 lbs 690 lbs Torque Specifications Conformity Certificates Conformity CertificatesUSA requirements Service Journal Service JournalDelivery Service Action Date, mtr reading, stamp, signAfter the First 5-8 Hours Hour Service English-77 English-78 English-79 At Least Once Each Year English-81 113331Rir06/14/06