American Standard 2003 installation instructions Repair Parts List, Description

		REPAIR PARTS LIST			2004.014		2004.314	2034.014	2034.314	2034.004
Repair parts are determined by toilet tank number which can be found marked inside tank.
NOTE: "XXX" represents color or trim finish options. Specify when ordering.
PART NO.		DESCRIPTION
738772-XXX0A		Champion®4 Trip Lever Assembly			✔		✔	✔	✔
735105-XXX0A		Champion®4 Chinaware Tank Cover			✔		✔	✔	✔
5325.01.XXX		Champion®4 Seat					✔		✔
738565-425.0070A		Champion®4 Water Control Assembly			✔		✔	✔	✔	✔
7301111-0070A		Champion®4 Valve Seal Kit			✔		✔	✔	✔	✔
3280.040-0070A		Champion®4 Flush Valve Assembly			✔		✔	✔	✔	✔
738826-0070A		Champion®4 Adapter Assembly - Kit #247			✔		✔	✔	✔	✔
738570-1020A		Champion®4 PVC Refill Tube			✔		✔	✔	✔	✔
738985-0070A		Champion®4 Clevis Pin Assembly			✔		✔	✔	✔	✔
738963-XXX0A		Traditional Trip Lever Assembly								✔
738126-XXX0A		Traditional Chinaware Tank Cover								✔
5260.012.XXX		Traditional Seat								✔
7301134-XXX0A		Traditional Bolt Cap Kit								✔
034783-XXX0A		Bolt Cap Kit - #128			✔		✔	✔	✔
072989-0070A		Refill Tube Clip			✔		✔	✔	✔	✔
			TROUBLESHOOTING GUIDE
PROBLEM		POSSIBLE CAUSE		CORRECTIVE ACTION
Does not flush	a. Water supply valve closed.			a. Open valve and allow water to fill tank.
	b. Supply line blocked.			b. Shut off water supply, disconnect supply line and inspect all
				gaskets and washers. Reassemble. Also, see Fluidmaster
				maintenance. (see Step 13)
	c. Flush valve chain too loose or disconnected.			c. Readjust chain length as required.
	d. Sand or debris lodged in water control.			d. Shut off water supply. Remove cap and clean as per Step 13.
Poor or sluggish flush	a. Bowl water level too low.			a. Check that refill tube is connected to water control and
				inserted into tank overflow without being kinked or damaged.
				(see Step 11a)
	b. Supply valve partly closed.			b. Open supply valve fully. Be sure that proper supply tube size
				is used.
	c. Partially clogged trapway and/or drain pipe and/or vent.			c. Remove obstruction. Consult a plumber if necessary.
	d. Supply pressure too low.			d. Normal supply pressure must be at least 20 psi.
	e. Flush valve chain too tight, holding flush valve open.			e. Readjust chain length as needed. Review Step 9b.
Toilet leaks	a. Poor supply line connection.			a. Review Step 8 of installation procedure.
	b. Poor bowl to tank/floor connection.			b. Review Step 4 through 6 of installation procedure.
Toilet does not shut off	a. Flush valve seal leaking or deformed.			a. Clean debris from seal surface. Replace flush valve seal as
				needed. (see Step 11)
	b. Sand or debris lodged in water control.			b. Shut off water supply. Remove cap and clean as per Step 13.
		CHAMPION® 4 FLUSHING SYSTEM TEN-YEAR WORRY-FREE™ LIMITED WARRANTY
For this warranty to become effective, the accompanying warranty registration card and proof of purchase must be completed and returned to the address on
the warranty registration card within 30 days of purchase.
If inspection of this American Standard plumbing product, inclusive of china and all mechanical components, within ten years after its initial purchase,
confirms that it is defective in materials or workmanship, American Standard will repair or, at its option, exchange the product for a similar model.
This warranty does not apply to local building code compliance. Since local building codes vary considerably, the purchaser of this product should check
with a local building or plumbing contractor to insure local code compliance before installation.
This warranty shall be void if the product has been moved from its initial place of installation; if it has been subjected to faulty maintenance, abuse, misuse,
accident or other damage; if it was not installed in accordance with American Standard's instructions; or if it has been modified in a manner inconsistent with
the product as shipped by American Standard.
This warranty DOES NOT COVER any damage caused by the use of in-tank cleaners.
American Standard's option to repair or exchange the product under this warranty does not cover any labor or other costs of removal or installation, nor shall
American Standard be responsible for any other incidental or consequential damages attributable to a product defect or to the repair or exchange
of a defective product, all of which are expressly excluded from this warranty. (Some states or provinces do not allow the exclusion or limitation of
implied warranties, so this exclusion may not apply to you.)
This warranty gives you specific legal rights. You may have other statutory rights that vary from state to state or from province to province, in which case this
warranty does not affect such statutory rights.
For service under this warranty, it is suggested that a claim be made through the contractor or dealer from or through whom the product was purchased, or
that a service request (including a description of the product			model and of the defect) be sent to the following address:
In the United States:			In Canada:				In Mexico:
American Standard Inc.			American Standard			Customer Service Manager
P.O. Box 6820			2480 Stanfield Rd.			Ideal Standard, S.A. de C.V.
Piscataway, New Jersey 08855			Mississauga, Ontario				Via Morelos #330
Attention: Director of	Consumer Affairs		Canada L4Y 1S2				Col. Santa Clara
For residents of the United States, warranty			Toll Free: (800) 387-0369			Ecatepec 55540 Edo. Mexico
information may also be obtained by calling			www.americanstandard.ca			www.americanstandard.com.mx
the following toll free number: (800) 442-1902

www.americanstandard-us.com

- 4 - 730865-100 Rev. H