|
| REPAIR PARTS LIST |
|
| 2004.014 | 2004.314 |
| 2034.014 |
| 2034.314 |
| 2034.004 | ||
| Repair parts are determined by toilet tank number which can be found marked inside tank. |
|
|
|
| |||||||||
|
|
|
|
|
|
|
|
|
| |||||
| NOTE: "XXX" represents color or trim finish options. Specify when ordering. |
|
|
|
|
|
|
|
|
|
| |||
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
| PART NO. |
| DESCRIPTION |
|
|
|
|
|
|
|
|
|
| |
|
| Champion®4 Trip Lever Assembly |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
|
| ||
|
| Champion®4 Chinaware Tank Cover |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
|
| ||
| 5325.010.XXX |
| Champion®4 Seat |
|
|
| ✔ |
|
|
| ✔ |
|
| |
| Champion®4 Water Control Assembly |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
| ✔ | |||
|
| Champion®4 Valve Seal Kit |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
| ✔ | ||
|
| Champion®4 Flush Valve Assembly |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
| ✔ | ||
|
| Champion®4 Adapter Assembly - Kit #247 |
| ✔ | ✔ |
| ✔ |
| ✔ |
| ✔ | |||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Champion®4 PVC Refill Tube |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
| ✔ | ||
|
| Champion®4 Clevis Pin Assembly |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
| ✔ | ||
|
| Traditional Trip Lever Assembly |
|
|
|
|
|
|
|
|
| ✔ | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Traditional Chinaware Tank Cover |
|
|
|
|
|
|
|
|
| ✔ | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| 5260.012.XXX |
| Traditional Seat |
|
|
|
|
|
|
|
|
| ✔ | |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Traditional Bolt Cap Kit |
|
|
|
|
|
|
|
|
| ✔ | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Bolt Cap Kit - #128 |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
|
| ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| Refill Tube Clip |
|
| ✔ | ✔ |
| ✔ |
| ✔ |
| ✔ | ||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| TROUBLESHOOTING GUIDE |
|
|
|
|
|
|
|
|
|
| |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
| PROBLEM |
| POSSIBLE CAUSE |
|
| CORRECTIVE ACTION |
|
|
|
|
| |||
| Does not flush | a. Water supply valve closed. |
| a. Open valve and allow water to fill tank. |
|
|
|
|
| |||||
|
| b. Supply line blocked. |
| b. Shut off water supply, disconnect supply line and inspect all |
| |||||||||
|
|
|
|
| gaskets and washers. Reassemble. Also, see Fluidmaster |
| ||||||||
|
|
|
|
| maintenance. (see Step 13) |
|
|
|
|
|
|
| ||
|
| c. Flush valve chain too loose or disconnected. |
| c. Readjust chain length as required. |
|
|
|
|
| |||||
|
| d. Sand or debris lodged in water control. |
| d. Shut off water supply. Remove cap and clean as per Step 13. |
| |||||||||
|
|
|
|
|
|
|
|
|
|
|
| |||
| Poor or sluggish flush | a. Bowl water level too low. |
| a. Check that refill tube is connected to water control and |
| |||||||||
|
|
|
|
| inserted into tank overflow without being kinked or damaged. |
| ||||||||
|
|
|
|
| (see Step 11a) |
|
|
|
|
|
|
| ||
|
| b. Supply valve partly closed. |
| b. Open supply valve fully. Be sure that proper supply tube size |
| |||||||||
|
|
|
|
| is used. |
|
|
|
|
|
|
|
|
|
|
| c. Partially clogged trapway and/or drain pipe and/or vent. |
| c. Remove obstruction. Consult a plumber if necessary. |
| |||||||||
|
| d. Supply pressure too low. |
| d. Normal supply pressure must be at least 20 psi. |
|
|
| |||||||
|
| e. Flush valve chain too tight, holding flush valve open. |
| e. Readjust chain length as needed. Review Step 9b. |
|
|
| |||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
| |
| Toilet leaks | a. Poor supply line connection. |
| a. Review Step 8 of installation procedure. |
|
|
|
|
| |||||
|
| b. Poor bowl to tank/floor connection. |
| b. Review Step 4 through 6 of installation procedure. |
|
|
| |||||||
|
|
|
|
|
|
|
|
|
|
|
| |||
| Toilet does not shut off | a. Flush valve seal leaking or deformed. |
| a. Clean debris from seal surface. Replace flush valve seal as |
| |||||||||
|
|
|
|
| needed. (see Step 11) |
|
|
|
|
|
|
| ||
|
| b. Sand or debris lodged in water control. |
| b. Shut off water supply. Remove cap and clean as per Step 13. |
| |||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
- 4 - |