Contact |
| ® | ||
Do not return to place of purchase. |
|
| ||
|
|
|
| |
|
|
|
| |
Troubleshooting |
|
|
| |
|
|
| ||
If the problem is: | And this condition exists: | Then do this | ||
Pilot won’t light | Cylinder valve is closed | Open valve | ||
|
|
| ||
| Blockage in orifice or pilot tube | Clean or replace orifice or pilot tube | ||
|
|
| ||
| Air in gas line | Open gas line and bleed it (pressing | ||
Note: Heater operates at reduced efficiency |
|
| control knob in) for not more than 1 - 2 | |
below 40ºF (5ºC). |
|
| minutes or until you smell gas | |
|
|
| ||
| Low gas pressure with cylinder valve | Turn cylinder valve OFF and replace | ||
| fully open | cylinder | ||
|
|
| ||
| Igniter fails | Use match to light pilot; obtain new | ||
|
|
| igniter and replace | |
|
|
| ||
Pilot won’t stay lit | Dirt built up around pilot | Clean dirt from around pilot | ||
|
|
| ||
| Connection between gas valve and | Tighten connection and perform leak | ||
| pilot assembly is loose | check | ||
|
|
| ||
| Thermocouple is not operating | Replace thermocouple | ||
| correctly |
| ||
|
|
| ||
Burner won’t light | Gas pressure is low | Turn cylinder valve OFF and replace | ||
|
|
| cylinder | |
|
|
| ||
| Blockage in orifice | Clear blockage | ||
|
|
| ||
| Control knob is not in ON position | Turn control knob to ON | ||
Burner flame is low | Gas pressure is low | Turn cylinder valve OFF and replace | ||
|
|
| cylinder | |
|
|
| ||
| Outdoor temperature is less than 40ºF | Use a full cylinder | ||
| and tank is less than 1/4 full |
| ||
|
|
| ||
| Supply hose is bent or kinked | Straighten hose | ||
|
|
| ||
| Control knob fully ON | Check burner and orifices for blockage | ||
|
|
| ||
Emitter glows uneven | Gas pressure is low | Turn cylinder valvue OFF and replace | ||
Note: Bottom 1” of emitter normally does |
|
| cylinder | |
NOT glow. |
|
|
| |
Base is not on a level surface | Place heater on a level surface | |||
| ||||
| Heater is level | Clean burner | ||
|
| |||
|
|
| ||
Carbon | Dirt or film on reflector and emitter | Clean reflector and emitter | ||
Thick black smoke | Blockage in burner | Remove blockage and clean burner | ||
|
|
| inside and outside | |
|
|
|
| |
Owner’s manual: model 153100 outdoor patio heater | 2/13/04 | 16 |