Carrier ASPAS1CCA007 Specifications, System SET LED, Fuel Requirements Recommendations

Section 1 — General Information

Carrier Air-cooled 7 kW, 12 kW and 15 kW Generators

1.5		SPECIFICATIONS
‹ 1.5.1 GENERATOR
Model			ASPAS1CCA007		ASPAS1CCA012	ASPAS1CCA015
Rated Max. Continuous Power Capacity (Watts*)			6,000 NG/7,000 LP		12,000 NG/12,000 LP	13,000 NG/15,000 LP
Rated Voltage			120/240		120/240	120/240
Rated Max. Continuous Load Current (Amps)
	120 Volts**		50.0 NG/58.3 LP		100.0 NG/100.0 LP	108.3 NG/125.0 LP
	240 Volts		25.0 NG/29.2 LP		50.0 NG/50.0 LP	54.2 NG/62.5 LP
Main Line Circuit Breaker			30 Amp		50 Amp	65 Amp
Phase			1		1	1
Number of Rotor Poles			2		2	2
Rated AC Frequency			60 Hz		60 Hz	60 Hz
Power Factor			1		1	1
Recommended Air Filter			Carrier Part # 0C8127		Carrier Part # 0C8127	Carrier Part # 0C8127
Battery Requirement			Group 26		Group 26	Group 26
(At 0° F -17.8°C)			12 Volts and		12 Volts and	12 Volts and
			350 Cold-cranking		525 Cold-cranking	525 Cold-cranking
			Amperes Minimum		Amperes Minimum	Amperes Minimum
Weight			375 Pounds		470 Pounds	487 Pounds
Output Sound Level @ 23 ft (7m) at full load			68 db (A)		70.5 db (A)	71.5 db (A)
Normal Operating Range				-20°F (-28.8°C) to 104°F (40°C)

*Maximum wattage and current are subject to and limited by such factors as fuel Btu content, ambient temperature, altitude, engine power and condition, etc. Maximum power decreases about 3.5 percent for each 1,000 feet above sea level; and also will decrease about 1 percent for each 6° C (10° F) above 16° C (60° F) ambient temperature.

**Load current values shown for 120 volts are maximum TOTAL values for two separate circuits. The maximum current in each circuit must not exceed the value stated for 240 volts.

‹1.5.2 ENGINE

	ASPAS1CCA007	ASPAS1CCA012	ASPAS1CCA015
Type of Engine	GH-410	GT-990	GT-990
Number of Cylinders	1	2	2
Rated Horsepower	14.5 @ 3,600 rpm	30 @ 3,600 rpm	30 @ 3,600 rpm
Displacement	410cc	992cc	992cc
Cylinder Block	Aluminum w/Cast	Aluminum w/Cast	Aluminum w/Cast
	Iron Sleeve	Iron Sleeve	Iron Sleeve
Valve Arrangement	Overhead Valves	Overhead Valves	Overhead Valves
Ignition System	Solid-state w/Magneto	Solid-state w/Magneto	Solid-state w/Magneto
Recommended Spark Plug	RC14YC	RC12YC	RC12YC
Spark Plug Gap	0.76 mm (0.030 inch)	0.508 mm (0.020 inch)	0.508 mm (0.020 inch)
Compression Ratio	8.6:1	9.5:1	9.5:1
Starter	12 Vdc	12 Vdc	12Vdc
Oil Capacity Including Filter	Approx. 1.5 Qts	Approx. 1.7 Qts	Approx. 1.7 Qts
Recommended Oil Filter	Carrier Part # 70185D	Carrier Part # 70185D	Carrier Part # 70185D
Recommended Air Filter	Carrier Part # 0C8127	Carrier Part # 0C8127	Carrier Part # 0C8127
Operating RPM	3,600	3,600	3,600

1.6SYSTEM SET LED

The “System Set” LED is lit when all of the following conditions are true:

1.The AUTO/OFF/MANUAL switch is set to the AUTO position.

2.The utility voltage being supplied to the unit is being sensed by the PCB. If the utility sense voltage is not connected to the unit or if it is below 168 volts AC, then the system set light will flash rapidly. This indicates that if the AUTO/OFF/ MANUAL switch is placed in the Auto position, the generator will start.

3.The “Not In Auto” dip switch is set to the OFF position on the control board.

4.No alarms are present, for example, low oil pressure, high temperature, etc.

1.7FUEL REQUIREMENTS

AND RECOMMENDATIONS

With LP gas, use only the vapor withdrawal system. This type of system uses the vapors formed above the liquid fuel in the storage tank. The engine has been fitted with a fuel carburetion system that meets the specifications of the 1997 California Air Resources Board for tamper-proof dual fuel systems. The unit will run on natural gas or LP gas, but it has been factory set to run on natural gas.

6 Carrier