Carrier ASPAS1CCA012, ASPAS1CCA015 manual

GENERAC

POWER SYSTEMS, INC.

Parts, Adjustment andMaintenance Manual

Air-cooled, Prepackaged

Automatic Standby Generators

Models:

ASPAS1CCA007 (6 kW NG, 7 kW LP)

ASPAS1CCA012 (12 kW NG, 12 kW LP)

ASPAS1CCA015 (13 kW NG, 15 kW LP)

DEADLY EXHAUST FUMES. OUTDOOR INSTALLATION ONLY!!

DANGER

Not intended for use as Primary Power in place of utility

or in life-support applications.

!!

Contents

Main Parts, Adjustment and Maintenance Manual !! INTRODUCTION ! READ THIS MANUAL THOROUGHLY DANGER CONTENTS Page GENERAL HAZARDS WARNING: ! DANGER ! ! WARNING: ELECTRICAL HAZARDS FIRE HAZARDS EXPLOSION HAZARDS STANDARDS INDEX 1.1 BEFORE INITIAL START-UP ! 1.2 CHECK TRANSFER SWITCH OPERATION DANGER DANGER 1.4 GENERATOR TESTS UNDER LOAD 1.5 CHECKING AUTOMATIC OPERATION 1.6 ADJUSTING THE REGULATOR (NATURAL GAS ONLY) Figure 1.1 Dual Fuel Regulators Figure 1.2 Placement of Regulator 1.7 RECONFIGURING THE FUEL SYSTEM 1.7.1 7 KW, 410CC ENGINE 1.7.2 12KW AND 15KW, V-TWIN ENGINES Figure 1.4 - Demand Regulator 1.8 ENGINE GOVERNOR ADJUSTMENT 1.8.1 7 KW UNITS Figure 1.5 Engine Governor Adjustment Single Cylinder Engines 1.8.2 12 KW AND 15 KW UNITS Figure 1.6 Engine Governor Adjustment V-twin Engines 1.9 VOLTAGE REGULATOR ADJUSTMENT Figure 1.8 Voltage Adjustment Potentiometer 1.10 ADJUSTING GH-410/GT-990 VALVE CLEARANCE Figure 1.9 - Valve Clearance Adjustment NOTES: 2.1 TROUBLESHOOTING GUIDE PROBLEM CAUSE CORRECTION 3.1 SERVICE SCHEDULE ATTENTION: It is recommended that all service work be performed by the nearest Carrier Dealer. Wiring Diagram Single Cylinder Drawing No. 0E9014 12 Carrier Carrier 13 BA N2 N1 CB1 Electrical Schematic Single Cylinder Drawing No. 0E9015 14 Carrier TX - TRANSFORMER, 16 Vac 56 VA & 16 Vac 1 VA GN ( Electrical Schematic Single Cylinder Drawing No. 0E9015 TX - TRANSFORMER, 16 Vac 56 VA & 16 Vac 1 VA (DUAL SEC.) Wiring Diagram V-Twin Drawing No. 0E9016 16 Carrier Carrier 17 -+ BA 10 8 9 Electrical Schematic V-Twin Drawing No. 0E9017 18 Carrier Carrier 19 Page Page Page Page Electical Schematic 8 Circuit Load Center Drawing No. 0E7815A 24 Carrier Carrier 25 Electical Schematic 10 and 12 Circuit Load Center Drawing No. 0E7815 Enclosu re Drawi ng No. 0E9161- D Enclosure Drawing No. 0E9161-D Control Panel Drawing No. 0E9162-H 28 Carrier Page Page Page Page Page Page Page 43 GN410 Engine Drawing No. 0F4716 Page 2 36 Carrier Page Page Page Page Page 7 kW Generator - Drawing No. 0D3504-D Page Page Page Page Carrier 47 REAR VIEW **ALL DIMENSIONS IN: "DO NOT LIFT BY THE TOP" Section 6 - Unit Dimensions Installation Drawing No. 0D3739-B