Right side panel removed for clarity

•Stand cart upright.

6 • This step requires two people to lift and position grill head onto cart.

•Carefully lower the grill head onto the cart. Make sure the regulator hose is hanging outside the cart. Attach with 1/4”-20x1/2” screws.

Grill Head

1/4"-20x1/2" Screw

Qty. 4

Page 20

Image 20

Char-Broil 463230510 manual Right side panel removed for clarity, 20x1/2 Screw Qty

Contents

Estimated assembly time 35-40 minutes Date Purchased Table of Contents This Grill is for Outdoor USE only Installation Safety Precautions California Proposition Temperature First Time UseLava Rock / Briquettes Pre-Heating Your Grill Food Safety Direct CookingIndirect Cooking Rotisserie Cooking Usda Recommended Safe Minimum Internal Temperatures Why Clean? General CleaningRoutine Care Storing Your Grill LP Cylinder Filling USE and CareLP Liquefied Petroleum Gas For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Nipple has to be centered into the LP cylinder valve Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lighting General Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame Check Cleaning the Burner Assembly Storing Your GrillVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinder Limited Warranty Items Manufacturer will not PAY for Parts List Key Qty Description Parts Diagram Assembly Flange nuts at rear20x2-3/8 Machine Screw Qty Flange Nut Qty Flange Nut Qty 20x2-3/8 Machine Screw Qty ScrewsMetal Tap Turn assembly upside down Right side panel removed for clarity 20x1/2 Screw Qty 20x1/2 Screw 7mm Fiber Washer Qty 20x1/2 Screw Back Firebox20x1/2 Machine Screw #8-32 wing nut Sideburner Tube Hinge Pin hole #10-24x1/2 Machine Screw QtyLeft Handle 5mm Flat Washer Qty Right Door Left Door 5mm Lock Washer Warming Rack Leg Wire Pivot Wire Cooking Grate AA Battery Bar Burner Heat Shield Grease TrayLP Cylinder Not included Tank Retainer Screw Problem TroubleshootingEmergencies Possible Cause Prevention/Solution Problem Possible Cause Prevention/Solution Possible Cause Prevention/Solution Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA