Hinge Pin hole, #10-24x1/2 Machine Screw Qty

12	•	Attach handle to door with #10-24x1/2” machine screws, 5mm flat washers and 5mm lock washers. (A).
	•	Insert hinge pin on bottom shelf into hole in door. Press upper hinge pin in front door brace, align hinge hole on top of door, and
		release hinge pin into door.

Hinge Pin hole

5mm Lock Washer

#10-24x1/2"

Machine Screw

Qty: 4

		#10-24x1/2"
	Left Handle	Machine Screw
	Left Handle	Right Handle
		Right Handle
		5mm Flat Washer

5mm Flat Washer

Qty: 4

Right Door

Left Door

5mm Lock Washer

Qty: 4

Page 24

Image 24

Char-Broil 463230510 manual Hinge Pin hole, #10-24x1/2 Machine Screw Qty, Left Handle

Contents

Estimated assembly time 35-40 minutes Date Purchased Table of Contents This Grill is for Outdoor USE only Installation Safety Precautions California Proposition Temperature First Time UseLava Rock / Briquettes Pre-Heating Your Grill Food Safety Direct CookingIndirect Cooking Rotisserie Cooking Usda Recommended Safe Minimum Internal Temperatures Why Clean? General CleaningRoutine Care Storing Your Grill USE and Care LP Liquefied Petroleum GasLP Cylinder Filling For your safety UseDo not household cleaning agents. Damage to gasLP Cylinder Leak Test Nipple has to be centered into the LP cylinder valve Leak Testing Valves, Hose and Regulator Connection, do not use this regulatorTurn all grill control knobs to OFF For Safe Use of Your Grill and to Avoid Serious Injury Ignitor LightingSDo not lean over grill while lighting Open lid during lighting General Grill Cleaning Sideburner Ignitor LightingSideburner Match Lighting Burner Flame Check Cleaning the Burner Assembly Storing Your GrillVery Important Burner tubes must reengage valve Turn gas OFF at control knobs and LP cylinder Limited Warranty Items Manufacturer will not PAY for Parts List Key Qty Description Parts Diagram Assembly Flange nuts at rear20x2-3/8 Machine Screw Qty Flange Nut Qty Screws Metal TapFlange Nut Qty 20x2-3/8 Machine Screw Qty Turn assembly upside down Right side panel removed for clarity 20x1/2 Screw Qty 20x1/2 Screw 20x1/2 Screw Back Firebox 20x1/2 Machine Screw7mm Fiber Washer Qty #8-32 wing nut Sideburner Tube Hinge Pin hole #10-24x1/2 Machine Screw QtyLeft Handle 5mm Flat Washer Qty Right Door Left Door 5mm Lock Washer Warming Rack Leg Wire Pivot Wire Cooking Grate AA Battery Bar Burner Heat Shield Grease TrayLP Cylinder Not included Tank Retainer Screw Troubleshooting Emergencies Possible Cause Prevention/SolutionProblem Problem Possible Cause Prevention/Solution Possible Cause Prevention/Solution Troubleshooting Electronic Ignition SectionPage Warranty Registration Department Box Columbus, GA