Ignitor Lighting (continued)

8.For grills equipped with ELECTRONIC IGNITION at each burner:

Repeat steps 4 through 6 to light each burner.

9.Once each burner has ignited, turn knobs to desired setting.

WARNING

Turn controls and gas source or tank OFF when not in use.

CAUTION

If ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury.

Match-Lighting

sDo not lean over grill while lighting.

1.Open lid. Turn ON gas at LP cylinder.

2.Place match into match holder (hanging from side panel of grill). Light match; then light burner by placing match through the match light hole on right or left side of grill.

3.Push in and turn far right or far left burner knob to the HI position, depending on match light hole selected. Be sure burner lights and stays lit.

4.Light adjacent burners in sequence by pushing knobs in and turning to the HI position.

Sideburner Ignitor Lighting

sDo not lean over grill while lighting.

1.Open sideburner lid. Turn ON gas at LP cylinder.

2.Turn sideburner knob to the HI position, push and hold ELECTRONIC IGNITOR button.

3.If sideburner does NOT light within 5 seconds, turn knob to OFF, wait 5 minutes, then

repeat lighting procedure.

Sideburner Match Lighting

1.Open sideburner lid. Turn ON gas at LP cylinder.

2.Place lit match near burner.

3. Turn sideburner knob to the HI position.

Be sure burner lights and stays lit.

Burner Flame Check

•Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW. You should see a smaller flame in LOW position than seen on HI. Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "Sudden drop or low flame" in the Troubleshooting Section.

HI

LOW

Turning Grill Off

•Turn all knobs to the OFFposition. Turn LP cylinder OFF by turning hand-wheel clockwise to a full stop.

Ignitor Check

•Turn gas off at LP cylinder. Press and hold electronic ignitor button. "Click" should be heard and spark seen each time between each collector box or burner and electrode. See "Troubleshooting" if no click or spark.

Valve Check

•Important: Make sure gas is off at LP cylinder before checking valves. Knobs lock in OFF position. To check valves, first push in knobs and release, knobs should spring back. If knobs do not spring back, replace valve assembly before using grill. Turn knobs to LOW position then turn back to OFF position. Valves should turn smoothly.

Hose Check

•Before each use, check to see if hoses are cut or worn. Replace damaged hoses before using grill. Use only valve/hose/regulator specified by manufacturer.

General Grill Cleaning

•Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a grill cleaner with scrub brush on insides of grill lid and bottom. Rinse and allow to completely air dry. Do not apply a caustic grill/oven cleaner to painted surfaces.

•Plastic parts: Wash with warm soapy water and wipe dry.

useDo not citrisol, abrasive cleaners, degreasers or a concentrated grill cleaner on plastic parts. Damage to and failure of parts can result.

•Porcelain surfaces: Because of glass-like composition, most residue can be wiped away with baking soda/water solution or specially formulated cleaner. Use nonabrasive scouring powder for stubborn stains.

•Painted surfaces: Wash with mild detergent or nonabrasive cleaner and warm soapy water. Wipe dry with a soft nonabrasive cloth.

•Stainless steel surfaces: To maintain your grill’s high quality appearance, wash with mild detergent and warm soapy water and wipe dry with a soft cloth after each use. Baked-on grease deposits may require the use of an abrasive plastic cleaning pad. Use only in direction of brushed finish to avoid damage. Do not use abrasive pad on areas with graphics.

•Cooking surfaces: If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

12

Page 11 Page 13
Page 12
Image 12
Char-Broil 463270311 manual Sideburner Ignitor Lighting, Sideburner Match Lighting, Burner Flame Check, Turning Grill Off
Page 11 Page 13

463270311 specifications

The Char-Broil 463270311 is a popular gas grill that combines convenience, efficiency, and impressive performance, making it a favorite among outdoor cooking enthusiasts. This model is designed to provide a seamless grilling experience, whether you're preparing a quick weeknight meal or hosting a weekend barbecue.

One of the standout features of the Char-Broil 463270311 is its innovative TRU-Infrared cooking technology. This unique system ensures even heat distribution across the cooking surface, eliminating cold and hot spots that can lead to uneven cooking. By using infrared heat, this grill also minimizes flare-ups, allowing for a more controlled cooking process. This technology not only enhances the flavor of your food but also contributes to quicker cooking times.

With a primary cooking area of 450 square inches, the Char-Broil 463270311 offers ample space to grill multiple items simultaneously. It comes equipped with four main burners, each producing up to 10,000 BTUs, providing a total of 40,000 BTUs of cooking power. This robust burner system allows for versatile cooking options, accommodating everything from searing steaks to gently roasting vegetables.

The grill features a porcelain-coated cast iron cooking surface, which provides excellent heat retention and is easy to clean. Additionally, the warming rack adds an extra 150 square inches of space, making it ideal for keeping cooked food warm or toasting buns while you finish grilling the main dishes.

Durability is another key characteristic of the Char-Broil 463270311. The grill is constructed with a sturdy stainless steel body, ensuring it can withstand the elements and maintain its appearance over time. The lid features a built-in temperature gauge, making it easy to monitor cooking temperatures without lifting the lid.

For added convenience, the grill is equipped with an electronic ignition system, allowing for quick and reliable start-ups with the push of a button. The side shelves provide extra workspace for food preparation and include tool hooks for easy access to grilling tools. Additionally, the grill is mounted on wheels, making it easy to move around your patio or backyard.

Overall, the Char-Broil 463270311 combines practicality with performance, making it an excellent choice for both beginner and seasoned grillers. With its advanced cooking technology, spacious cooking area, and durable construction, this grill ensures that outdoor cooking is a pleasurable and efficient experience.
Top Page Image Contents