Char-Broil 463821909 specification

Attach handle to front of lid with silicon washers , insulation washers and #10-24 wing nuts. Upper lid hinges attach to back with

#10-24x1/2" machine screws, fiber washers and #10-24 flange nuts. Do not tighten the screws.

Handle

#10-24 Wing Nut

Qty:2

#10-24X1/2”

Machine Screw Lid Qty:4

Silicon Washer

Qty:10

Upper Lid Hinge

#10-24 Insulation Washer

Flange NutsQty:2

Qty:4

Place lid assembly onto firebox, aligning hinges. Hinges on lid fit inside hinges on firebox. Secure with

hinge pins and hitch pins. Tighten upper lid hinges screws.

1” Hitch Pin

Qty. 2

Hinge Pin

Qty. 2

Page 22

Image 22

Contents

Estimated assembly time 30 minutes Date Purchased Table of Contents This Grill is for Outdoor USE only Installation Safety Precautions California Proposition Lava Rock / Briquettes TemperatureFirst Time Use Pre-Heating Your Grill Indirect Cooking Food SafetyDirect Cooking Rotisserie Cooking Usda Recommended Safe Minimum Internal Temperatures Routine Care Why Clean?General Cleaning Storing Your Grill LP Cylinder Filling USE and CareLP Liquefied Petroleum Gas UL listed Overfill Protection UseDo not household cleaning agents. Damage to gas Connecting Regulator To The LP TankFor your safety LP Tank Exchange Turn all grill control knobs to OFF Leak Testing Valves, Hose and RegulatorConnection, do not use this regulator Shelf fascia not Shown for clarity Ignitor Lighting Safety TipsFor Safe Use Of Your Grill And To Avoid Serious Injury SDo not lean over grill while lighting Burner Flame Check Sideburner Ignitor LightingSideburner Match Lighting Hose Check Turn gas off at control knobs and LP cylinder Cleaning the Burner AssemblyCorrect burner-to-valve engagement Burner Tube Valve Limited Warranty Statement REV Disclaimer of Implied Warranties and Limitation of Remedies Description Parts ListNot Pictured Parts Diagram Leg Extender AssemblyCone side of wheel against leg Axle Bolt Qty.2 #10-24 X Machine Screw Qty.4 #10-24 Flange Nut Machine screws and silicon washers Burner Assembly #10-24 x ½ Machine Screws#10-24 Screw Qty #10-24x2Wing Screw #10-24x2 Valve Carriage Bolts #10-24 X Flange Nuts Qty8 #10-24 X ½ Qty4 Machine Screw Lower Hinge #10-24 Wing Screw QtyCenter flat portion of hinge on bottom Page Pivot Wire Swing Away Leg Cooking Grate Heat Tent Tank Wire Troubleshooting Emergencies Possible Cause Prevention/Solution Electronic Ignition

Char-Broil 463821909 manual

Models: 463821909