Page 14SKU 94678 for technical questions, please call 1-800-444-3353.

Maintenance cHart

refer to a small engine service manual for procedures not explained in this manual. if you are uncertain about your ability
to successfully and safely perform any procedure below, service should be performed by a qualified mechanic.
Maintenance type
before/
after each
use
Monthly or
20 hours
every 3
Months or
50 hours
every 6
Months or
100 hours
yearly or
300 hours
Check Engine Oil Level
Inspect for damage
Wipe off outside with clean,
slightly moist cloth
1.
2.
3. X
Change Engine Oil
Clean Air Filter (69)
(Replace Filter as needed)
1.
2. XXXX
Clean Deposit Cup (76)
(Clean monthly in dusty areas) XXX
Clean Spark Plug (44)
(Replace as needed) X X
Engine Overhaul
refer to a small engine service
manual for procedures. service is
to be performed only by a qualified
mechanic and includes:
Valve Clearance Check/Adjust
Clean Combustion Chamber
Clean Fuel Tank, Filter, and Supply
Line (replace filter and line as needed)
1.
2.
3.

X

troublesHootinG

problem possible causes probable solutions

Engine will not start Fuel Tank empty.
Fuel Valve(s) closed.
Choke not in proper start position.
ON/OFF Switch off.
Oil level low.
Spark Plug damaged, gapped incorrectly, or
connected improperly.
Mechanical/electrical problem.
1.
2.
3.
4.
5.
6.
7.
Check fuel level at Fuel Meter (1a).
Put Valves (9a, 81) in ON position.
Move Choke Control left to start.
Turn switch to ON position.
Check engine oil level.
Check Spark Plug gap, condition, and
connection.
Have qualified mechanic inspect and repair.
1.
2.
3.
4.
5.
6.
7.
Engine is running, but
power is not being supplied
to outlets.
Circuit Protection (59a, 53a) tripped. Pilot
Light (56a) will be off.
Electrical problem.
1.
2.
Reduce electrical load and reset Circuit
Protection (53a).
Have a qualified technician service unit.
1.
2.