AIR FILTER
Your engine will not run properly using a dirty air filter. Clean the foam
100 hours of operation or every season, whichever occurs first.
Service air cleaner more often under dusty conditions.
1.Remove knob and cover.
2.Remove wing nut and air cleaner from base.
TO SERVICE PRE-CLEANER
3.Slide foam
4.Wash it in liquid detergent and water.
5.Squeeze it dry in a clean cloth. Allow it to dry.
6.Saturate it in engine oil. Wrap it in
clean, absorbent cloth and squeeze to remove excess oil.
TO SERVICE CARTRIDGE
1.Replace a dirty, bent, or damaged cartridge.
NOTE: Do not wash the paper cartridge or use pressurized air, as this will damage the cartridge.
2.Reinstall the
3.Reassemble air cleaner, wing nut, cover and tighten knob securely.
Air Cleaner
Cover _ | Knob | |
Foam \ | Nut | |
Rubber | ||
Pre- \ | ||
Cleaner ' |
|
Paper
Cartridge
Air Cleaner
Base
Fill Cap/
ScreenDipstick
CLEAN AIR SCREEN
Air screen must be kept free of dirt and chaff to prevent engine damage from overheating. Clean with a wire brush or compressed air to remove dirt and stub- born dried gum fibers.
MUFFLER
Inspect and replace corroded muffler and
spark arrester (if equipped) as it could cre- ate a fire hazard and/or damage.
SPARK PLUG(S)
Replace spark plug(s) at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first. Spark plug type and gap setting are shown in "PRODUCT SPECIFICATIONS" section of this manual.
IN-LINE FUEL FILTER
The fuel filter should be replaced once each season. If fuel filter becomes
clogged, obstructing fuel flow to carbu- retor, replacement is required.
1.With engine cool, remove filter and plug fuel line sections.
2.Place new fuel filter in position in fuel
line with arrow pointing towards carbu- retor.
3.Be sure there are no fuel line leaks and clamps are properly positioned.
4.Immediately wipe up any spilled gaso- line.
_ |
| Clamp |
Clamp / | k,_ | .J...__ |
|
| _ Fuel Filter |
CLEANING
•Clean engine, battery, seat, finish, etc. of all foreign matter.
•Keep finished surfaces and wheels free of all gasoline, oil, etc.
•Protect painted surfaces with auto- motive type wax.
We do not recommend using a garden hose or pressure washer to clean your tractor unless the engine and transmis- sion are covered to keep water out. Water in engine or transmission will shorten the useful life of your tractor. Use compressed
air or a leaf blower to remove grass, leaves and trash from tractor and mower.
20
