CLEARING DISCHARGE LINES
Sanitation hoses should be cleared if toilet will not be needed for an extended period of time (more than two weeks).
1.Fill toilet bowl with water and add 4 oz. (120 ml) of biodegradable laundry detergent (should NOT contain bleach).
2.Flush toilet, holding pedal down for about two minutes. Close flush ball.
3.Turn off water supply to toilet.
4.Flush the toilet without water, allowing the vacuum pump to shut off after the flush. Repeat three times. (This procedure will minimize any remaining water in the sanitation hoses.)
5.Turn off power to the vacuum pump.
6.Completely pump out holding tank.
If system will be subjected to freezing temperatures, please follow above procedure, then winterize system as described in this manual.
MAINTENANCE
Maintenance intervals and normal parts replacement vary widely depending on numerous factors such as: type of vessel, frequency of system use, quality of flushing water, etc. The chart below is intended strictly as a general guideline. Owner discretion and consideration of actual usage must be the first basis for determining proper maintenance levels.
Maintenance Procedure | Part Number | Approximate Maintenance Level |
|
|
|
Follow cleaning procedures (page 5). | — | Monthly |
Tighten all clamps, including base clamp ring.* | — | Annually |
Check all wire connections. | — | Annually |
Check & tighten water valve mounting screws. | — | Annually |
Clean filter screen in water valve. | — | Annually |
Check pump and | 385310076 (2) | |
Check toilet seals. | 385316140 | |
Check vacuum breaker. | 385316906 | |
Check water valve. | 385314349 | |
|
|
|
*See Base Assembly - Page 10. |
|
|
|
|
|
SPARE PARTS |
|
|
|
|
|
To calculate total spare parts required, determine number and type of toilets and pumps.
On Board Spare Parts Calculation Chart: (Per System)
Type of System |
| Toilet | Toilet | S Pump | M Pump | Toilet | Vacuum | Toilet | Toilet | Vacuum | ||||
Toilet Series | Pump Series | Seal | Water | Duckbill | Duckbill | Vacuum | Tank | Ring/ | Ball/Shaft | Generator | Vacuum | |||
& Quantity | & Quantity | Kit | Valve | Valve Kit | Valve Kit | Breaker | Vacuum | Clamp | Cartridge | Switch | Generator | |||
|
|
|
|
|
| Kit |
|
|
| Switch | Kit | Kit | Kit | Switch Kit |
500+ | 1000 | S |
| M |
|
|
|
| ||||||
1 |
| 1 |
|
| 1 each | 1 each | 2 each |
|
|
|
|
|
|
|
2 |
| 2 |
|
| 1 each | 1 each | 2 each |
| 1 each |
|
| 1 each |
|
|
| 1 | 1 |
|
| 1 each | 1 each | 2 each |
|
|
|
|
|
|
|
| 2 | 2 |
|
| 1 each | 1 each | 2 each |
| 1 each |
|
| 1 each |
|
|
1 |
|
|
| 1 | 1 each | 1 each |
| 4 each |
|
|
|
|
|
|
2 |
|
|
| 1 | 1 each | 1 each |
| 4 each | 1 each |
|
| 1 each |
|
|
3 |
|
|
| 1 | 1 each | 1 each |
| 4 each | 1 each | 1 each | 1 each | 1 each | 1 each | 1 each |
4 |
|
|
| 1 | 2 each | 2 each |
| 4 each | 2 each | 1 each | 1 each | 1 each | 1 each | 1 each |
5 |
|
|
| 1 | 2 each | 2 each |
| 4 each | 2 each | 1 each | 1 each | 1 each | 1 each | 1 each |
6 |
|
|
| 1 | 2 each | 2 each |
| 4 each | 2 each | 2 each | 2 each | 2 each | 2 each | 2 each |
| 1 |
|
| 1 | 1 each | 1 each |
| 4 each |
|
|
|
|
|
|
| 2 |
|
| 1 | 1 each | 1 each |
| 4 each | 1 each |
|
| 1 each |
|
|
| 3 |
|
| 1 | 1 each | 1 each |
| 4 each | 1 each | 1 each | 1 each | 1 each | 1 each | 1 each |
| 4 |
|
| 1 | 2 each | 2 each |
| 4 each | 2 each | 1 each | 1 each | 1 each | 1 each | 1 each |
| 5 |
|
| 1 | 2 each | 2 each |
| 4 each | 2 each | 1 each | 1 each | 1 each | 1 each | 1 each |
| 6 |
|
| 1 | 2 each | 2 each |
| 4 each | 2 each | 2 each | 2 each | 2 each | 2 each | 2 each |
Per Vessel: Vacuum Tester – 530002 (1 each) & Owner’s Manual – (1 each)
6