PERFORMANCE DATA NO LOAD & NO DOOR OPENINGS AT 37°/0°
CONTROL SETTING (2500++ V4 CONTROLS)
SERVICE DATA SHEET - 242173700
FREEZER ICE MAKER - AUTOMATIC DEFROST
BOTTOM FREEZER - R134a
ICE MAKER INFORMATION
Test Cycling: Remove cover by inserting screwdriver in notch at bottom and prying cover from housing. Use screwdriver to rotate motor gear counter- clockwise until holding switch circuit is completed. All components of ice maker should function to complete the cycle.
Variable Speed Compressor | 65°F (18°C) Ambient | 90°F (32°C) Ambient | |
|
|
| |
Operating Time | 32 to 40% | 100% | |
|
|
| |
Freezer Temperature | |||
| |||
|
|
| |
Refrigerator Temperature | 33° to 46°F | 33° to 46°F | |
0.5° to 8°C | 0.5° to 8°C | ||
| |||
|
|
| |
Low Side Pressure | 5 to 12 psig | N/A | |
34 to 83 kPa |
| ||
|
|
| |
Low Side Pressure | |||
|
|
| |
High Side Pressure | 85 to 95 psig | 120 to 135 psig | |
586 to 655 kPa | 827 to 931 kPa | ||
| |||
|
|
| |
Wattage | 40 to 55 | 60 to 70 |
IMPORTANT SAFETY NOTE
The information provided herein is designed to assist qualified repair personnel only. Untrained persons should not attempt to make repairs due to the possibility of electrical shock. Disconnect power cord before servicing this appliance.
IMPORTANT
If any green grounding wires are removed during servicing, they must be returned to their original position and properly secured.
Water Fill Volume: The water fill adjust- ment screw will change the fill time. One full turn is equal to 20cc (.68 oz.). The correct fill is 102 to 130cc (3.4 to 4.3 oz.). When a water valve is replaced, the fill volume must be checked.
Water Fill
Adjustment
Motor
Gear
TUR
N
Mounting
Plate
Screw
Mounting
Plate
Screws
Timing
Gear
Amps (running) |
| 0.5 to 1.1 |
| 0.7 to 0.9 | |||
|
|
|
|
|
|
|
|
Base Voltage |
| 115 vac (127 vac max) |
|
|
| ||
|
|
|
|
|
|
|
|
| DEFROST SPECIFICATIONS |
|
|
| |||
|
|
|
|
|
|
|
|
Cabinet Size |
| Thermostat |
|
| Heater | ||
|
|
|
|
|
|
| |
|
| Watts |
| Ohms | |||
|
|
|
| ||||
|
|
|
|
|
|
|
|
23’ SD, 28’ SD, 23’ CD |
| 25°F | 47°F |
| 500 |
| 26 |
| (8°C) |
|
|
|
| ||
|
|
|
|
|
| ||
|
|
|
|
|
|
|
|
Electronic Timer - (ADC) Defrost 24 minutes every
CONDENSER FAN MOTOR
CAUTION
All electrical parts and wiring must be shielded from torch flame. DO NOT allow torch to touch insulation; it will char at 200°F and flash ignite (burn) at 500°F. Excessive heat will distort the plastic liner.
NOTE
This product comes equipped with an Adaptive Defrost Control (ADC). To activate
LINE
/ ORG
POWER
ICE MAKER
NEUTRAL
BLUE/
Watts | RPM |
| Amps |
|
|
|
|
3.1 | 1100 CW |
| 0.03 Running |
(Energy Star, some models) | Opposite Shaft |
| |
|
| ||
|
|
|
|
FREEZER ICE MAKER SPECIFICATIONS |
| ||
|
|
| |
Electrical | 115 vac (127 vac max) |
| |
|
| ||
Thermostat | Opens at 48°F (9°C), Closes at 15°F | ||
|
|
| |
Heater Voltage | 85 vac |
| |
|
| ||
FREEZER ICE MAKER CONNECTOR PLUG CONNECTIONS | |||
|
|
| |
Wire Number | Wire Color | Connects to: | |
|
|
| |
1 | Green / Yellow | Ground | |
|
|
| |
2 | Yellow / Blue | Water Valve |
manual defrost, simultaneously press and hold the Fresh Food up (+) and Fresh Food down
IMPORTANT
BLK
ICE MAKER
GRN / YEL
BLK
THERMAL
BLK
GRN / YEL
BRN
MOTOR |
|
| RED |
|
|
|
|
|
|
|
|
| |
HOLD |
|
|
|
|
|
|
SWITCH NO |
| YEL |
|
|
| |
RED | NC | THERMOSTAT |
| YEL |
| |
C |
|
| ||||
|
|
|
| NO | RED | |
|
|
|
|
| ||
BLK |
|
| BLU |
|
| |
|
|
| NC |
| ||
|
|
|
| C |
| |
|
|
|
|
|
| |
MOLD HEATER |
|
|
| SHUTOFF |
| |
165 WATTS |
|
| NO |
| ||
|
|
|
| SWITCH |
| |
|
|
|
|
|
| |
|
| C | NC |
| LT. BLUE |
|
|
|
|
|
|
|
YEL
ICE MAKER
BLUE | WATER VALVE |
LT. |
|
3 | Black / Orange | Line |
|
|
|
4 | Light Blue | Neutral |
PLEASE RETURN THIS SHEET TO ITS ORIGINAL LOCATION.
MOLD | MOUNTING |
| WATER FILL |
| PLATE |
| SWITCH |
| ICE MAKER | ||
|
|
| |
|
|
|
|