Empire Comfort Systems VFSR-16-3 Introduction, Save this manual for future reference, Btuh, Model

INTRODUCTION

IMPORTANT: Read all instructions carefully before starting installation. Failure to follow these installation instructions may result in a possible fire hazard and will void the warranty.

Save this manual for future reference.

Please read this manual before installing and using the appliance. Instructions to Installer

1.Installer must leave instruction manual with owner after installation.

2.Installer must have owner fill out and mail warranty card supplied with unvented room heater/vented decorative appliance.

3.Installer should show owner how to start and operate unvented room heater/vented decorative appliance.

Always consult your local Building Department regarding regulations, codes or ordinances which apply to the installation of an unvented room heater/vented decorative appliance.

This appliance may be installed in an aftermarket* manufactured (mobile) home, where not prohibited by state or local codes.

*Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer.

This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases.

New Installation

VFSV Model - variable does not operate-ON is OFF/OFF is ON-wires into the back of receiver are reversed.

Solid-fuels shall not be burned in a fireplace where a vented decorative appliance is installed.

A vented decorative appliance must be installed only in a solid-fuel burning fireplace with a working flue and constructed of non-combustible material.

Any alteration of the original design, installed other than as shown in these instructions or use with a type of gas not shown on the rating plate is the responsibility of the person and company making the change.

Important

All correspondence should refer to complete Model Number, Serial Number and type of gas.

Attention: During initial use of log you will detect an odor as the log is cured.

Notice: During initial firing of this unit, its paint will bake out, and smoke will occur. To prevent triggering of smoke alarms, ventilate the room in which the unit is installed.

WARNING: This appliance is for installation only in a solid- fuel burning masonry or UL 127 factory-built fireplace or in a listed ventless firebox enclosure. It has been design certified for these installations. Exception: DO NOT install this appliance in

afactory-built fireplace that includes instructions stating it has not been tested or should not be used with unvented gas logs.

WARNING: Any modification to this unvented gas heater or its controls can be dangerous. Improper installation or use of the heater can cause serious injury or death from fire, burns, explosion or carbon monoxide poisoning.

Well Head Gas Installations

Some natural gas utilities use "well head" gas. This may affect the Btu output of the unit. Contact the gas company for the heating value. Contact the manufacturer or your gas company before changing spud/ orifice size.

ACCESSORIES

	Description	Color
For use with VFSV and VFSR models
EK-1	Embers Kit
ELH-1	Fireplace Hood for Vent-Free Logs	Black
ELH-2	Fireplace Hood for Vent-Free Logs	Brass
For use with VFSR models only
FRBC	Battery Operated Remote Control
FRBTC	Battery Operated Remote Control with Thermostat
FREC	Electric Remote Control
FWS	Wall Switch
GWSG-T	Wall Thermostat, Millivolt
TMV	Wall Thermostat, Millivolt - Reed Switch

PRODUCT SPECIFICATION

			Natural Gas				Propane Gas
		Variable		Millivolt		Variable	Millivolt
Regulator pressure setting		3.5" W.C.		3.5" W.C.		10.0" W.C.	10.0" W.C
Gas inlet pressure	Max.	10.5" W.C.	10.5" W.C.			13.0"W.C.	13.0" W.C.
	Min.	5.0" W.C.		5.0" W.C.		11.0" W.C.	11.0" W.C.
					BTUH		BTUH
Model	Gas	Valve Type			Max. Rate	Min. Rate
VFSV-16	Natural		Variable		25,000		17,500
VFSV-16	Propane		Variable		22,500		15,750
VFSR-16	Natural		Millivolt		25,000		17,500
VFSR-16	Propane		Millivolt		22,500		15,750
VFSV-18	Natural		Variable		32,000		19,000
VFSV-18	Propane		Variable		32,000		19,000
VFSR-18	Natural		Millivolt		32,000		22,000
VFSR-18	Propane		Millivolt		32,000		22,000
VFSV-24	Natural		Variable		36,000		20,000
VFSV-24	Propane		Variable		36,000		20,000
VFSR-24	Natural		Millivolt		36,000		25,000
VFSR-24	Propane		Millivolt		36,000		25,000
VFSV-30	Natural		Variable		38,000		20,000
VFSV-30	Propane		Variable		38,000		20,000
VFSR-30	Natural		Millivolt		38,000		26,000
VFSR-30	Propane		Millivolt		38,000		26,000

14008-0-0403 Page 5