EV9797-22
Kleensteam II Twin System
Everpure's second generation of total water treatment system for steam applications
| B E N E F I T S | |
|
| |
Kleensteam II Twin System: | A total system delivering high quality filtered | |
| water with scale inhibition and deliming | |
7CB5 Replacement Cartridge: | capabilities | |
| ||
| New dual cartridge design provides enhanced | |
performance for low or high flow capacity | ||
steamers | ||
| ||
| Fine filters incoming water to improve the | |
| performance, maximize energy efficiency and | |
| increase the life of steam equipment | |
| Reduces | |
| System is simple to install, operate and maintain | |
| Easy deliming with Everpure's ScaleKleen, which | |
| is fed directly into the boiler through the | |
| bowl without use of hazardous chemicals or | |
| special piping | |
| Long lasting | |
| higher alkalinty/hardness/TDS/temperature | |
| installations. | |
| Sophisticated Hydroblend compound prevents | |
| limescale formation in high temperature steam | |
| applications |
I N S T A L L A T I O N T I P S | O P E R A T I O N T I P S | A P P L I C A T I O N / S I Z I N G |
|
|
|
Choose a mounting location suitable to support | Change 7CB5 cartridge on a regular 6 month | For commercial steam applications |
the full weight of the system when operating | preventative maintenance program, when capacity |
|
| is reached or when pressure falls below 10 psi | For use with foodservice steamer and |
Use minimum 1/2” inlet water line (3/4” |
| applications |
preferred) | Change |
|
| compound is completely used up | The Kleensteam II Twin System is shipped with |
Connect the system to the boiler feed water line |
| two 7CB5 cartridges and no filter head plug |
only! Do not connect to the condenser water line! | Service flow rate must not exceed 2.5 gpm for |
|
| single cartridge systems or 5.0 for dual cartridge |
|
Install vertically with cartridges hanging down | systems |
|
Allow | Always flush the filter cartridge at time of |
|
easy cartridge replacement | installation and cartridge change |
|
Flush cartridges by running water through filter | Use for periodic deliming as needed by installing |
|
for five minutes at full flow | the dip tube assembly in place of the |
|
| dissolving Scale Kleen in |
|
| deliming instructions are provided with the |
|
| system |
|
|
|
|