Exmark 00 & Higher, 850 Check Spark Plugs, Change Fuel Filter, Service Interval Every 160 hours

Models: 00 & Higher 850

1 44
Download 44 pages 57.61 Kb
Page 23
Image 23
Check Spark Plugs

Maintenance

Lubrication Chart (cont'd.)

Fitting

Initial

Number of Places

Service

Locations

Pumps

 

 

 

Interval

6. Trans-

2

2

2

2

40

mission

 

 

 

 

hours

Output

 

 

 

 

 

Shaft

 

 

 

 

 

Coupler

 

 

 

 

 

7. Mower

2

1

1

1

40

Deck

 

 

 

 

hours

Idler

 

 

 

 

 

Pivots

 

 

 

 

 

Check Spark Plugs

Service Interval: Every 160 hours

Remove spark plugs, check condition and reset gaps, or replace with new plugs. See Engine Owner’s Manual.

Change Fuel Filter

Service Interval: As required

A fuel filter is installed in the fuel line between the fuel tank and the engine. Replace when necessary.

48 inch Deck Shown for Reference Only

Number 4 and 7 (Idler Arm Pivots) Disassemble and grease once a month under a “No Load” condition

Number 6 (Transmission Coupler) Located

below fuel tank support

3.Replace 5-speed gearbox grease yearly. Use 18 oz. of Peerless grease (Part No. 788067). See Check

Grease Level, Input and Output Shaft Bearing Wear on Peerless Transmission section for special lubrication instructions.

4.Lubricate pivot points with a spray penetrating lubricant as shown in the Spray Lubricant Chart.

Spray Lubricant Chart

 

Number of Places

 

 

 

 

 

 

Pivot Points

32 inch

36 inch

48 inch

Service

 

Deck

Deck

Deck

Interval

1. Blade

1

1

1

40 hours

Engagement

 

 

 

 

Bellcrank

 

 

 

 

Check Grease Level, Input and Output Shaft Bearing Wear on Peerless Transmission

Service Interval: Every 160 hours—Check grease level, input and output shaft bearing wear on Peerless Transmission.

Yearly—Replace gearbox grease.

1.Stop engine, wait for all moving parts to stop, and remove key. Engage parking brake. Remove key or spark plug wire(s).

2.Place drive levers and neutral lock/park brake latches in neutral lock position

3.Remove shifter lever from top of transmission.

4.Remove shifter plate from top of transmission and the two leads from the neutral start switch.

5.Release the tension on the transmission belt.

6.Check for side play caused by bearing wear on the input and output shafts of the transmission. Replace bearings if necessary.

7.Remove the six bolts that fasten the upper case to the lower case and carefully remove the upper case half

8.Check the grease level in the lower case. The grease level should be approximately 1 1/2 inch to 1 3/4 inch (3.8 to 4.4 cm) from the gearbox bottom. If necessary, fill to proper level with Peerless grease (Part No. 788067).

23

Page 23
Image 23
Exmark 00 & Higher Check Spark Plugs, Change Fuel Filter, Service Interval Every 160 hours, Yearly-Replacegearbox grease