Generac Power Systems 009592-5, 009735-5 NOTICE TO INSTALLER

18 Generac®Power Systems, Inc.

Safety Rules

PRIMEPACT 55G and 55LP Recreational Vehicle Generators

NOTICE TO INSTALLER

These Installation Instructions have been published

by Generac to aid in the installation of the products

described in this manual. Generac assumes that

installation personnel are familiar with the proce-

dures for installing such products, or similar prod-

ucts that Generac manufactures. Generac also

assumes that personnel have been trained in the rec-

ommended installation procedures for these prod-

ucts and that such training includes (a) use of com-

mon hand tools, (b) use of special Generac tools, and

pliers.

Generac cannot possibly know of and advise the

recreational vehicle trade of all conceivable methods,

procedures or techniques by which to perform an

installation. Nor can Generac anticipate every possi-

ble hazard that might result from each installation

method, procedure or technique. Generac has not

undertaken any such wide evaluation. Therefore,

people who use a method, procedure or technique

that Generac does not specifically recommend must

first completely satisfy themselves that their safety,

the safety of the vehicle's occupants and the product's

safety is not endangered by the method, procedure or

technique selected.

Information, illustrations, specifications, etc., con-

tained in these Installation Instructions are based on

the latest information available at the time of publi-

cation. Every effort has been expended to be sure that

such data is both accurate and current. However, the

manufacturer reserves the right to change, alter or

otherwise improve this product at any time without

prior notice.

Despite the safe design of this generator,

operating this equipment imprudently, neglecting

its maintenance or being careless can cause

possible injury or death. Permit only responsible

and capable persons to operate or maintain this

equipment.

Potentially lethal voltages are generated by

these machines. Ensure all steps are taken to

render the machine safe before attempting to

work on the generator.

Parts of the generator are rotating and/or hot

during operation. Exercise care near running

generators.

GENERAL HAZARDS

• For safety reasons, Generac recommends

that the installation, initial start-up and mainte-

nance of this equipment is carried out by a

Generac Authorized Service Dealer.

• The engine exhaust fumes contain carbon monox-

ide, which can be DEADLY. This dangerous gas, if

breathed in sufficient concentrations, can cause

unconsciousness or even death. This exhaust sys-

tem must be installed properly, in strict compli-

ance with applicable codes and standards.

Following installation, you must do nothing that

might render the system unsafe or in noncompli-

ance with such codes and standards. The genera-

tor compartment must be completely vapor sealed

from the vehicle interior. There must be no possi-

bility of exhaust fumes entering the vehicle interi-

or. Never operate this equipment with a leaking or

defective exhaust system.

• Keep hands, feet, clothing, etc., away from drive

belts, fans, and other moving or hot parts. Never

remove any drive belt or fan guard while the unit is

operating.

• Adequate, unobstructed flow of cooling and venti-

lating air is critical to correct generator operation

and is required to expel toxic fumes and fuel

vapors from the generator compartment. Without

sufficient cooling airflow, the engine/generator

quickly overheats, which causes serious damage to

the generator. Do not alter the installation or per-

mit even partial blockage of ventilation provisions,

as this can seriously affect safe operation of the

generator.

• When working on this equipment, remain alert at

all times. Never work on the equipment when you

are physically or mentally fatigued.

• Before performing any maintenance on the genera-

tor, disconnect its battery cables to prevent acci-

dental start up. Disconnect the cable from the bat-

tery post indicated by a NEGATIVE, NEG or (–)

first. Reconnect that cable last.

• Never use the generator or any of its parts as a

step. Stepping on the unit can stress and break

parts, and may result in dangerous operating con-

ditions from leaking exhaust gases, fuel leakage,

oil leakage, etc.

• Never insert any tool or other object through open-

ings in the generator interior, even if the unit is not

running. You might seriously injure yourself or

damage the equipment.

DANGER: For fire safety, installation of a generator into a recreational vehicle must comply strictly

with article 551, NFPA 70; ANSI C1-1975; AND, ANSI A119.2-1975/NFPA 501C “Standard for

Recreational Vehicles” (Part 3, “Installation of Electrical Systems”). In addition, installation must

comply with the manufacturer’s instructions and recommendations.