Housing (89) before each use. Be sure it is in good condition, and is firmly installed on the road sweeper.
6.Have a qualified service technician periodically service the Gasoline Engine (68).
7.Over time the Brush will wear down and may not contact the pavement. To adjust Brush height, remove the Front Caster Wheels by pulling out the Retaining
Pin (27). Remove 1 Plastic Ring from the lower part of the Caster Wheel Axle. Replace the Caster Wheel with the Plastic Ring on the top. Replace the Retaining Pin.
TroubleShooting - Engine
Symptom |
| Possible Cause |
| Possible Remedy | ||
Engine Will |
|
|
|
|
|
|
| Fuel Valve is OFF |
|
| Turn Valve to OPEN Position |
| |
Not Start |
|
|
|
| ||
| Fuel Tank is Empty |
|
| Fill Fuel Tank |
| |
|
|
|
|
| ||
|
| Choke in Open Position |
|
| Close Choke |
|
|
| Spark Plug is Dirty |
|
| Clean and Gap Spark Plug |
|
|
| Spark Plug Wire is |
|
| Clean and Tighten Spark Plug Wire |
|
|
| Loose or Disconnected |
|
|
|
|
|
| Technical Problem |
|
| Service by a Qualified Technician |
|
|
|
|
|
|
|
|
Engine Runs |
|
|
|
|
|
|
| Gasoline is Wrong Type |
|
| Drain Tank and Refill with 86 Oc- |
| |
Rough, |
|
|
|
| ||
|
|
|
| tane or Higher Unleaded Gasoline |
| |
Pings or Dies |
|
|
|
|
| |
| Gasoline is dirty or has |
|
| Drain Tank and Replace with Clean |
| |
|
| Water or Oil in it |
|
| Fresh Gasoline |
|
|
| Fuel Level is Very Low |
|
| Fill Fuel Tank |
|
|
|
|
|
|
|
|
Engine Shuts |
|
|
|
|
| |
| Low Oil Level Shut Off |
|
| Check Oil Level, Add if Needed |
| |
Off By Itself, |
|
|
|
|
|
|
| Loose or Damaged |
|
| Check Spark Plug Wire, Replace if |
| |
But Has Fuel |
|
|
|
| ||
| Spark Plug Wire |
|
| Needed |
| |
|
|
|
|
| ||
|
| Other Technical Problem |
|
| Service by a Qualified Technician |
|
|
|
|
|
|
|
|
Engine Does |
|
|
|
|
|
|
| Choke Closed |
|
| Open Choke when Engine is Warm |
| |
Not Reach |
|
|
|
| ||
| Gasoline is Contami- |
|
| Drain Tank and Replace Fuel |
| |
Full Speed |
|
|
|
| ||
| nated |
|
|
|
| |
|
|
|
|
|
| |
|
| Air Filter is Clogged |
|
| Clean or Replace Air Filter |
|
|
| Other Technical Problem |
|
| Service by a Qualified Technician |
|
|
|
|
|
|
|
|
SKU 96456 | For technical questions, please call | Page 10 |
