Hearth and Home Technologies GRL-700-AU manual Introduction, Assembly

1.0INTRODUCTION

Model GRL-700-AU Gas Log Sets are Decorative Gas Appliances for Installation in a Solid-Fuel Burning Fire- place. Minimum fireplace size for GRL-700-AU: height 425mm, width 700mm, depth 300mm.

This log set is to be installed only in a solid-fuel burn- ing fireplace with a working flue and one constructed of noncombustible material or into an approved Jetmaster gas firebox. The minimum permanent vent opening pro- vided by the fireplace chimney damper to vent the flue products must not be less than 40,000mm2. The chim- ney damper MUST be fixed in a fully opened position and the fireplace must have a proper draft.

WARNING: OPEN THE CHIMNEY DAMPER TO

!ITS FULLY OPEN POSITION WHEN BURNING THIS GAS LOG SET.

WARNING: LOGS MUST NEVER BE BURNED

!WITHOUT THE FLUE DAMPER IN THE FULL OPEN POSITION. FAILURE TO DO SO IS DAN- GEROUS TO YOUR HEALTH AND VOIDS ALL WARRANTIES.

WARNING: ALL GAS APPLIANCES PRO- ! DUCE SOME CARBON MONOXIDE WHEN OPERATED. CARBON MONOXIDE IS A COLOR- LESS, ODORLESS, POISONOUS GAS. ADE- QUATE PROVISIONS MUST BE MADE TO PRO- VIDE COMBUSTION AIR FOR THIS GAS LOG SET. IF OUTSIDE AIR IS NOT INCLUDED IN THE FIRE- PLACE, IT MAY BE NECESSARY THAT AN ADDI- TIONAL COMBUSTION AIR SOURCE BE PROVIDED.

WARNING: LOGS OTHER THAN THOSE

!SUPPLIED WITH THIS UNIT MUST NOT BE USED.

CAUTION: To minimize the possibility of spillage and to maximize proper draft, position the log set as close to the back of the fireplace as possible.

The installation, including provisions for combustion and ventilation air, must conform with the AGA Gas Instal- lation Code.

Do not use this appliance if any part has been under water. Immediately call a qualified service technician to inspect the unit and to replace any part of the control system and any gas control which has been underwater.

CAUTION: DO NOT PLACE ARTICLES ON OR AGAINST THIS APPLIANCE.

CAUTION: DO NOT USE OR STORE FLAMMABLE MATERIALS NEAR THIS APPLIANCE.

CAUTION: DO NOT SPRAY AEROSOLS IN THE VI- CINITY OF THIS APPLIANCE WHILE IT IS IN OP- ERATION.

!WARNING: THIS UNIT IS NOT FOR USE WITH SOLID FUEL. SOLID FUELS SHALL

NOT BE BURNED IN A FIREPLACE WHERE A DECORATIVE APPLIANCE IS INSTALLED.

TO REDUCE THE RISK OF FIRE OR INJURY FROM BURNS AND FOR THE PROTECTION OF YOUNG CHILDREN OR THE INFIRM, A SECONDARY GUARD IS RECOMMENDED.

2.0ASSEMBLY

CAUTION: WHEN INSTALLING THIS LOG SET IN A FACTORY BUILT FIREPLACE, BE CERTAIN TO CONSULT THE FIREPLACE INSTALLATION MANUAL. ALL KNOCKOUTS IN THE FIREPLACE THROUGH WHICH THE GAS SUPPLY LINE IS RUN MUST BE RESEALED WITH INSULATION AFTER THE GAS LINE IS IN PLACE.

Model GRL-700-AU contains complete gas-burner, decorative front, and log components needed. Use cau- tion when handling logs to avoid damage. Position gas- burner assembly to the rear of the fireplace. Once fully assembled slide access door into place.

5