Johnson Controls TM9V080B12MP11, TM9V100C20MP11 dimensions LED Indicator, Clearances, Dimensions

QUICK REFERENCE GUIDE

96%TWO STAGE MULTI-POSITION RESIDENTAL

GAS FURNACES (33” TALL)

NOTES:

1. If the furnace is equipped with NOx screens and is to be

used with LP (propane) gas, the screens must be removed

7. To measure total static pressure, add supply duct pressure

to the return duct pressure, add pressure drop across the ‘A’

This document does not replace the installation instructions, which must be referred to for detailed information.

	prior to start-up.
2.	Drip leg in the gas line must be installed.
3.	The furnace controls require correct polarity on the power
	supply and a proper ground.
4.	Y & G must be connected to the control board for cooling
	operation.
5.	External filters are required on all configurations.
6.	Electrical or gas entry is available on both casing sides.

	coil, and add pressure drop across the filter. Ignore negative
	signs on the readings.
8.	Inlet gas pressure should be 7” w.c. for natural gas and 11”
	w.c. for propane. Nominal manifold gas pressure is 3.5” w.c.
	for natural gas and 10” w.c. for propane at max. input.
9.	For downflow application the vent blower must be rotated 90
	left or right as shown.

	SUPPLY END		2” Diameter	RETURN END
.56”
	23.8”	3”	Vent Connection
			Outlet

B	Combustion
	Air Inlet

DURING INSTALLATION, DOORS MUST REMAIN ON FURNACE WHEN MOVING

BOR LIFTING.

Clips can be flipped into the up position

	Airflow CFM (Bottom Return without Filters)												Minimum Wire			Maximum
Models			0.5" ESP (Nominal)†										Size awg @ 75'			Over Current
													One-Way			Protection
	*D-A**		*C-A**				*B-A**			*A-B**
TM9V060B12MP11	600			690			1000			1305			14					15
TM9V080B12MP11	600			680			1000			1290			14					15
TM9V080C16MP11	850			905			1175			1670			14					15
TM9V100C16MP11	870			910			1160			1655			14					15
TM9V100C20MP11	960		1155				1605			2215			12					20
TM9V120D20MP11	960		1160				1595			2180			12					20
	Input				Total Unit			Air Temp. Rise			Air Temp. Rise			Time For 1 ft			3	Natural Gas
Models	Rate
						Amps		Max Input °F				Min Input °F		(1030 Btu/Ft3) Seconds
	Max	Min													(On Max. Rate)
TM9V060B12MP11	60,000	21,000				9			35 - 65			35 - 65			62
TM9V080B12MP11	80,000	28,000				9			35 - 65			30 - 60			46
TM9V080C16MP11	80,000	28,000				12			35 - 65			35 - 65			46
TM9V100C16MP11	100,000	35,000				12			35 - 65			30 - 60			37
TM9V100C20MP11	100,000	35,000				14			35 - 65			35 - 65			37
TM9V120D20MP11	120,000	42,000				14			35 - 65			35 - 65			31

†Other airflows are available. see Tech Guide for all CFM options. * Cool Tap.

** Adjustment Tap.

.56”	.56”		24.25”
	20”
	Combustion Air Inlet		Combustion Air Inlet
	Condensate Drain	Gas Pipe
	(Downflow)		Condensate Drain
		Entry
			(Downflow)
	Vent Connection
		Electrical
	Outlet
		Entry	Vent Connection
		Condensate	Outlet
		Drain	23”
		Thermostat
		Wiring
			Optional Return Air
			Cutout (Either side)
	28.5”		1.5”
	29.5”
	LEFT SIDE		RIGHT SIDE

Follow all national and local codes and standards in addition to this document. The installation must comply with regulations of the serving gas supplier, local building, heating, plumbing, and other codes. In absence of local codes, the installation must comply with national codes and all authorities having jurisdiction.

for coil cabinet or plenum attachment

A-COIL

14”

1”

33”

AFRONT

LED INDICATOR

Slow Green Flash - Normal operation in standby mode. Slow Amber Flash - Normal operation with call for cooling. Two Amber Flashes - Normal operation with call for heat.

Three Amber Flashes - Normal operation, burner is on at end of thermostat cycle.

Six Amber Flashes - Normal operation with call for heat pump heating.

Any Red Flash - Fault condition. NOTE: 4 or 5 flashes may indi- cate a blown fuse on the circuit board.

Subject to change without notice. Printed in U.S.A.	*438336*	438336-URG-A-0209
Copyright © 2009 by Johnson Controls, Inc. All rights reserved.		Supersedes: Nothing

Johnson Controls Unitary Products

5005 York Drive

Norman, OK 73069

CLEARANCES

Application	Upflow	Downflow	Horizontal
Top	1"	0"	0"
Vent	0"	0"	0"
Rear	0"	0"	0"
Side	0"	0"	1"
Front*	0"	0"	0"
Floor	Combustible	Combustible1	Combustible
Closet	Yes	Yes	Yes
Line Contact	No	No	Yes

1. For combustible floors only when used with special sub-base.

*24" clearance in front and 18" on side recommended for service access.

All furnaces approved for alcove and attic installation.

DIMENSIONS

Cabinet Size	A (in)	B (in)
All 'B' Cabinet Furnaces	17-1/2"	16-3/8"
All 'C' Cabinet Furnaces	21"	19-7/8"
All 'D' Cabinet Furnaces	24-1/2"	23-3/8"