Impeller ROD, Traction ROD, Shifter ROD TOP

REPAIR PARTS SNOW THROWER - - MODEL NUMBER MC627ES (96192004102)

HANDLES

KEY	PART	DESCRIPTION
NO.	NO.	DESCRIPTION
1	180480	IMPELLER ROD
2	405740	TRACTION ROD

180445

SHIFTER ROD TOP

8 9

4	187716	SHIFTER ROD BOTTOM
5	180447	SPRING SLEEVE
6	178669	IMPELLER SPRING
7	180926	TRACTION SPRING
8	72270505	CARRIAGE BOLT 5/16-18 X .625

9	155377	NUT 5/16-18
10	169675	RETAINER

01.12.001-E

NOTE: All component dimensions given in U.S. inches. 1 inch = 25.4 mm

IMPORTANT: Use only Original Equipment Manufacturer (O.E.M.) replacement parts. Failure to do so could be hazardous, damage your snow thrower and void your warranty. 28

Page 28

Image 28

McCulloch 96192004102 Impeller ROD, Traction ROD, Shifter ROD TOP, Shifter ROD Bottom, Spring Sleeve, Impeller Spring

Contents

MC627ES Safe Operation Practices for Walk-Behind Snow Throwers Table of Contents Assembly / PRE-OPERATION HOW to SET UP Your Snow ThrowerParts Packed Separately in Carton Remove Snow Thrower from Carton Install Traction Drive Control ROD See Figs Install Speed Control ROD See FigsUnfold Upper Handle Install Discharge Chute / Chute Rotater Head See Fig Install Auger Control ROD See FigsCheck Tire Pressure Operation Know Your Snow ThrowerPrimer Ignition KEY Meets A.N.S.I. Safety Requirements Electric start button used for starting the engine HOW to USE Your Snow Thrower StoppingTo USE Fuel SHUT-OFF Valve See Fig To USE Choke Control See Fig To Throw Snow See Fig Using the CLEAN-OUT Tool See FigTo Move Forward and Backward See Fig To Adjust Skid Plates See Fig Before Starting the EngineScraper BAR See Fig Check Engine OIL Level See Fig Snow Throwing Tips To Start EngineBefore Stopping If Recoil Starter has Frozen Maintenance General RecommendationsBefore Each USE Lubrication Cleaning Engine Service and Adjustments To Adjust Snow Thrower HeightChute Deflector Shear Bolts See Fig To Replace Belts See Fig To Adjust Cable Tension See Fig To Remove Wheels See FigCarburetor Engine Speed Storage OtherFuel System Engine OIL Troubleshooting Exploded KEY Part Description Auger Housing Scraper BARAuger 27 LH Auger 27 RH Auger Bearing Bearing PlugSkid Plate LH Skid Plate RH Chute Weldment Deflector WeldmentDeflector Seal Strap LEVER/CABLE Rotator Assembly Cable Assembly AdjustableCable Assembly Heat Shield Rotator Head 196944X431 Panel Bracket LH 196943X431 Panel Bracket RH Handle GripLower Handle Pivot Support Weldment Spacer RetainerKnob RED Handle Knob Impeller ROD Traction RODShifter ROD TOP Shifter ROD Bottom Wire Harness Console PanelHeadlight Bezel Flood Headlight Repair Parts Snow Thrower - Model Number MC627ES Drive Assembly Drive Plate AssemblySpeed Selector Rubber Ring Axle Shaft Roll PIN 3/16Sprocket Clik PIN Complete LCT Engine Frame427963X428 Engine Mounting Plate Impeller Belt Traction BeltIdler ARM Bracket Idler Pulley 432331X421 Wheel Assembly LH432332X421 Safety Ignition KEY 422663 181037 DECAL, Danger Service Notes Service Notes Limited Warranty

McCulloch 96192004102 owner manual Impeller ROD, Traction ROD, Shifter ROD TOP, Shifter ROD Bottom

Models: 96192004102

REPAIR PARTS SNOW THROWER - - MODEL NUMBER MC627ES (96192004102)

KEY

IMPELLER ROD

TRACTION ROD

SHIFTER ROD TOP

SHIFTER ROD BOTTOM

SPRING SLEEVE

IMPELLER SPRING

TRACTION SPRING

RETAINER