|
|
| TROUBLESHOOTING | |
|
|
|
|
|
| TABLE 7. ENGINE TROUBLESHOOTING |
| ||
|
|
|
|
|
| SYMPTON | POSSIBLE CAUSE | SOLUTION |
|
|
|
|
|
|
|
| Spark plug bridging? | Check gap, insulation or |
|
|
| replace spark plug. |
| |
|
|
|
| |
|
|
|
|
|
| Difficult to start, "fuel is available, but no | Carbon deposit on spark plug? | Clean or replace spark plug. |
|
| SPARK at spark plug". | Short circuit due to deficient spark plug | Check spark plug insulation, |
|
|
|
| ||
|
| insulation? | replace if worn. |
|
|
|
|
|
|
|
| Improper spark plug gap? | Set to proper gap. |
|
|
|
|
|
|
|
| ON/OFF switch is shorted? | Check switch wiring, replace |
|
|
| switch. |
| |
|
|
|
| |
|
|
|
|
|
|
| Ignition coil defective? | Replace ignition coil. |
|
|
|
|
|
|
| Difficult to start, "fuel is available, and | Improper spark gap, points dirtry? | Set correct spark gap and |
|
| clean points. |
| ||
| SPARK is present at the spark plug". |
|
| |
|
|
|
| |
|
| Condenser insulation worn or short | Replace condenser. |
|
|
| circuiting? |
| |
|
|
|
| |
|
|
|
|
|
|
| Spark plug wire broken or short circuiting? | Replace defective spark plug |
|
|
| wiring. |
| |
|
|
|
| |
|
|
|
|
|
|
| Wrong fuel type? | Flush fuel system, and replace |
|
|
| with correct type of fuel. |
| |
|
|
|
| |
| Difficult to start, "fuel is available, spark |
|
|
|
| Water or dust in fuel system? | Flush fuel system. |
| |
| is present and compression is normal" |
| ||
|
|
|
|
|
|
| Air cleaner dirty? | Clean or replace air cleaner. |
|
|
|
|
|
|
|
| Suction/exhaust valve stuck or protruded? |
| |
|
|
|
|
|
|
| Piston ring and/or cylinder worn? | Replace piston rings and or |
|
|
| piston. |
| |
| Difficult to start, "fuel is available, spark |
|
| |
|
|
|
| |
|
|
|
| |
| is present and compression is low" | Cylinder head and/or spark plug not | Torque cylinder head bolts and |
|
|
| tightened properly? | spark plug. |
|
|
|
|
|
|
|
| Head gasket and/or spark plug gasket | Replace head and spark plug |
|
|
| damaged? | gaskets. |
|
|
|
|
|
|
|
| Fuel not available in fuel tank? | Fill with correct type of fuel. |
|
|
|
|
|
|
|
| Fuel cock does not open properly? | Apply lubricant to loosen fuel |
|
|
| cock lever, replace if necessary. |
| |
|
|
|
| |
| No fuel present at carburetor. |
|
|
|
| Fuel filter clogged? | Replace fuel filter. |
| |
|
|
| ||
|
|
|
|
|
|
| Fuel tank cap breather hole clogged? | Clean or replace fuel tank cap. |
|
|
|
|
|
|
|
| Air in fuel line? | Bleed fuel line. |
|
|
|
|
|
|
MVC77 PLATE COMPACTOR — OPERATION AND PARTS MANUAL — REV. #4 (1/14/11) — PAGE 23
