Manuals / Murray / Lawn and Garden / Lawn Mower

Murray 309007x8B manual Assembly, Parts Bag − Contents, Loose Parts − Contents

Models: 309007x8B

1 52

Download 52 pages 39.85 Kb

Page 10

ASSEMBLY

ASSEMBLY

ASSEMBLY

Read and follow the assembly and adjustment instructions for your mower. All fasteners are in the parts bag. Do not discard any parts or material until the unit is assembled.

NOTE: In this instruction book, left and right describe the loca- tion of a part with the operator on the seat.

WARNING: Before doing any assembly or mainte- nance to the mower, remove the wire from the spark plug.

PARTS BAG − CONTENTS

The fasteners and other loose parts are shown below. The fasteners are shown full size. The quantity is shown in brackets ( ).

2x82	14x79	690604
(2) Carriage Bolt	(2) Wing Nut	690604
		(1) Cover, Terminal

1001054	17x47	(2) Ignition Key
(2) Knob	(2) Washer

LOOSE PARTS − CONTENTS

Steering Colar

Steering Wheel

And Post

Seat

Literature Kit

Hardware Pack

Side Discharge Attachment

F−050611L

10

Image 10

Murray 309007x8B manual Assembly, Parts Bag − Contents, Loose Parts − Contents

Contents

This Instruction Book Contains Information Model309007x8B PRODUCT INFORMATIONTABLE OF CONTENTS MURRAY, INC. Two Year Limited WarrantyRESPONSIBILITY OF THE OWNER SAFETY RULESOWNER’S INFORMATION I. General operationIII. Children IV. ServiceII. Slope operation OWNER’S INFORMATIONSAFE MOWING GUIDE mower was completely assembled at the store, you must still check the mower according to the assembly instructions. Make sure the mower is correctly assembled and that all fasteners are tight. Make sure the engine has the correct amount of oil. Check these items often during the life of the mower SAFE MOWING GUIDErunning. Before you service the unit, even with the engine stopped SAFE MOWING GUIDEWHILE MOWING STEPS TO FOLLOWBEFORE MOWING AFTER MOWINGINTERNATIONAL PICTORIALS INTERNATIONAL PICTORIALSPARTS BAG − CONTENTS ASSEMBLYASSEMBLY LOOSE PARTS − CONTENTSHOW TO ASSEMBLE THE STEERING WHEEL HOW TO INSTALL THE SEATASSEMBLY HOW TO INSTALL THE BATTERY CABLES MAINTENANCE FREE BATTERYHOW TO CHARGE THE MAINTENANCE FREE BATTERY ASSEMBLYIMPORTANT! BEFORE YOU START MOWING HOW TO PREPARE THE ENGINECHECK THE LEVEL OF THE MOWER HOUSING CHECK THE TIRESBLADE ROTATION CONTROL Use the blade rotation OPERATIONLOCATION OF CONTROLS LIFT LEVERATTACHMENTS ELECTRICAL SAFETY SYSTEMHOW TO OPERATE THE IGNITION KEY SWITCH OPERATIONHOW TO USE THE BLADE ROTATION CONTROL HOW TO USE THE THROTTLE / CHOKE CONTROLOPERATION OPERATION HOW TO USE THE SHIFT LEVERSee the Instruction Book for the Attachment HOW TO STOP THE UNIT HOW TO SET THE PARKING BRAKEHOW TO CHANGE THE CUTTING HEIGHT HOW TO TRANSPORT THE UNITHOW TO INSTALL THE SIDE DISCHARGE ATTACHMENT OPERATIONCARBURETOR HOW TO START THE ENGINEBEFORE STARTING THE ENGINE OPERATIONHOW TO OPERATE THE UNIT ON HILLS HOW TO OPERATE WITH THE MOWER HOUSINGOPERATION MOWING AND BAGGING TIPS OPERATING TIPSOPERATION MAINTENANCE REQUIRED MAINTENANCEMAINTENANCE CHART HOW TO CHECK THE MUFFLERINSPECT BLADE HOW TO REMOVE AND INSTALL THE BLADEHOW TO SHARPEN THE BLADE MAINTENANCE2. Move the blade rotation control to the DISENGAGE position Figure MAINTENANCEHOW TO CHECK THE BLADE ROTATION CONTROL 8. Move the blade rotation control to the ENGAGE positionMAINTENANCE HOW TO CHECK AND ADJUST THE DRIVE BRAKEHOW TO CHECK AND ADJUST THE CLUTCH Adjustable NutMAINTENANCE FREE BATTERY HOW TO ADJUST THE SHIFT LEVERMAINTENANCE HOW TO REMOVE THE BATTERYMAINTENANCE WHERE TO LUBRICATEHOW TO CHECK THE FUEL FILTER NOTE Apply grease to the steering gear assemblyHOW TO LEVEL THE MOWER HOUSING MAINTENANCEHOW TO INSTALL THE MOWER HOUSING HOW TO REMOVE THE MOWER HOUSINGMAINTENANCE INSTALLATION HOW TO REPLACE THE MOTION DRIVE BELTMAINTENANCE REMOVALHOW TO REPLACE THE MOWER DRIVE BELT MAINTENANCEFront Wheel HOW TO INSTALL THE WHEELSMAINTENANCE Rear WheelTHE BATTERY HOW TO REPLACE THE FUSEHOW TO CLEAN THE MOWER HOUSING CLEAN THE UNITTROUBLE SHOOTING CHART BROWN & WISER, INC CPT CANADA POWER TECHNOLOGY LIMITEDBILLIOU’S, INC FRANK EDWARDS COF−050611L MODEL 309007x8B REPAIR PARTS CHASSIS & HOODF−050611L CHASSIS & HOOD REPAIR PARTSMODEL 309007x8B MOTION DRIVE REPAIR PARTSMODEL 309007x8B MODEL 309007x8B REPAIR PARTSMOTION DRIVE REPAIR PARTS STEERINGMODEL 309007x8B MODEL 309007x8B REPAIR PARTSSTEERING MODEL 309007x8B MOWER HOUSING SUSPENSIONREPAIR PARTS F−050611LMODEL 309007x8B REPAIR PARTSMOWER HOUSING SUSPENSION DescriptionMODEL 309007x8B MOWER HOUSINGREPAIR PARTS F−050611LMODEL 309007x8B REPAIR PARTSMOWER HOUSING DescriptionWIRING HARNESS FOR 30” MID−ENGINE RIDER 2004 MAIN HARNESS ELECTRICAL SYSTEMREPAIR PARTS MODEL 309007x8BMODEL 309007x8B REPAIR PARTSELECTRICAL SYSTEM F−050611L INDEX Make your Mid-Engine Rider do more than you ever imagined MID-ENGINE RIDER ACCESSORIES