socket wrench. Spark plug gap should |
| Start engine and allow to run until it stops. | ||||||||||||
be 0.025 inches. |
|
| S | Clean the unit before storing. Pay particu- | ||||||||||
6. Reinstall the spark plug boot. |
|
|
| lar attention to the air intake area, keeping | ||||||||||
7. Reinstall the cylinder cover and 3 screws. |
| it free of debris. Use a mild detergent and | ||||||||||||
Tighten securely. |
|
|
| sponge to clean the plastic surfaces. | ||||||||||
Screws | Cylinder | S | Do not store the unit or fuel in a closed area | |||||||||||
|
|
|
|
|
|
|
|
| Cover |
| where fuel vapors can reach sparks or an | |||
Spark |
|
|
|
|
|
|
|
| open flame from hot water heaters, electric | |||||
|
|
|
|
|
|
|
|
|
|
| ||||
Plug Boot |
|
|
|
|
|
|
| motors or switches, furnaces, etc. | ||||||
|
|
|
|
|
|
|
|
|
|
| S | Store in a dry area out of the reach of chil- | ||
|
|
|
|
|
|
|
|
|
|
|
| dren. | ||
Spark |
|
| CAUTION: It is important to prevent gum | |||||||||||
|
| deposits from forming in essential fuel system | ||||||||||||
Plug |
|
| ||||||||||||
|
| parts such as the carburetor, fuel filter, fuel | ||||||||||||
|
|
|
|
|
|
|
|
|
|
| ||||
STORAGE |
|
| hose, or fuel tank during storage. Alcohol | |||||||||||
|
| blended fuels (called gasohol or using ethanol | ||||||||||||
WARNING: Stop engine and allow | or methanol) can attract moisture which leads | |||||||||||||
to fuel mixture separation and formation of | ||||||||||||||
to cool, and secure the unit before storing or | acids during storage. Acidic gas can damage | |||||||||||||
transporting in a vehicle. Store unit and fuel | the engine. | |||||||||||||
in an area where fuel vapors cannot reach |
|
|
| |||||||||||
|
|
| ||||||||||||
sparks or open flames from water heaters, |
|
|
| |||||||||||
electric motors or switches, furnaces, etc. |
|
|
| |||||||||||
Store unit with all guards in place. Position so |
|
|
| |||||||||||
NEED ASSISTANCE? | ||||||||||||||
that any sharp object cannot accidentally | ||||||||||||||
cause injury to passersby. Store the unit out | Call | |||||||||||||
of reach of children. |
|
| NEED SERVICE PART? | |||||||||||
S Before storing, drain all fuel from the unit. | Contact your authorized service dealer. | |||||||||||||
TROUBLESHOOTING TABLE
WARNING: Always stop unit and disconnect spark plug before performing all of the recommended remedies below except remedies that require operation of the unit.
TROUBLE | CAUSE | REMEDY | ||
|
|
|
| |
Engine will not | 1. Ignition switch off. | 1. | Move ignition switch to ON. | |
start or will run | 2. Engine flooded. | 2. | See “Difficult Starting” in | |
only a few |
|
|
| Operation Section. |
seconds after | 3. Fuel tank empty. | 3. | Fill tank with correct fuel mixture. | |
starting. | 3. Spark plug not firing. | 4. | Install new spark plug. | |
| 4. Fuel not reaching | 5. | Check for dirty fuel filter; replace. | |
|
| carburetor. |
| Check for kinked or split fuel line; |
|
|
|
| repair or replace. |
|
|
|
| |
Engine will | 1. | Carburetor requires | 1. Contact an authorized service dealer. | |
not idle |
| adjustment |
|
|
properly. | 2. | Crankshaft seals worn. | 2. Contact an authorized service dealer. | |
|
|
|
| |
Engine will not | 1. | Air filter dirty. | 1. Clean or replace air filter. | |
accelerate, | 2. | Spark plug fouled. | 2. Clean or replace plug and regap. | |
lacks power, | 3. | Chain brake engaged. | 3. Disengage chain brake. | |
or dies under | 4. | Carburetor requires | 4. Contact an authorized service dealer. | |
a load. |
| adjustment. |
|
|
|
|
|
| |
Engine | 1. Too much oil mixed with | 1. | Empty fuel tank and refill with | |
smokes |
| gasoline. |
| correct fuel mixture. |
excessively. |
|
|
|
|
15
