Raypak 1802B-2342B warranty Heat Exchanger, Controls, Gas Train Options, Burner, Venting

Job:		Hi Delta® - Type P
Engineer:		Commercial Pool Heaters
Contractor:
			Models 1802B-2342B
Prepared By:	Date:
Model:	Indoor/Outdoor:		MBTUH Input:

Sealed Combustion Chamber

100% Factory Fire Tested

Efficiency: 85%

Minimum Non-condensing Inlet Temperature: 105°F

Thermal Shock Proof Heat Exchanger

Limited Twenty-year Thermal Shock Warranty

Limited Five-year Heat Exchanger Warranty

Diagnostic Center with Fault History

PolyTuf Powder Coated Cabinet

No Combustible Floor Shield Required

Fan-assisted

Non-ferrous Bypass

Patented Burner Security Blanket

Heat Exchanger

￿Bronze Headers

￿ASME Inspected and Stamped 160 PSIG Working Pressure

￿National Board Approved

￿Cupro Nickel Finned Tubing

￿ASME Steel Tube Sheet

￿Silicone High Temp O-Rings

￿125 PSIG ASME Pressure Relief Valve

￿Temperature and Pressure Gauge

￿Water Connections

Left – Standard

Right – Option A-6

￿Bronze Pump, 120V, 60Hz

￿Non-ferrous Pool Bypass

Controls

￿120V, 60Hz, 1∅ Power Supply

￿120/24V 60Hz Transformer

￿100% Shut-off/Lockout

￿Hot Surface Ignition Systems (2)

￿Remote Flame Sensors (2)

￿High Limit Control, Auto Reset

￿On/Off Power Switch

￿Manual Shut-off, Front-mounted

￿Flow Switch

￿Blocked Vent Pressure Switch

￿Combustion Air Proving Switches

￿Economaster Pump Time Delay

￿Poolstat

Gas Train		Options
￿	Gas Pressure Regulators		C-6	Ignition Module, Manual Reset
￿	Safety Shut-off Valves		D-21	TruSeal™ Direct Vent
￿	Firing Control Valves			Right Side
￿	On/Off Firing			Left Side (Model 1802B
￿ Low Gas Pressure Switch, Manual				Only)
￿	Fuel		F-10	Low Water Cut-off, Remote
	Natural Gas			Probe
	Propane Gas		S-2	Dual High Gas Pressure
￿ Design Certified ANSI Z21.56/				Switches, Manual Reset
	CSA 4.7		X-1	SureRack Kit, Zone III and IV
Burner			X-2	SureRack Add-on, Zone IV
			Y-241	Temperature Controller,
￿ Ultra-low NOx:
				1-4 Stages
	Less than 30 PPM
Construction		Regulatory Agency Requirements
			G-1	CSD-1

￿Indoor/Outdoor Construction

￿Enclosed Front Controls

Venting

￿Vent Location

Top – Standard

Rear – Option D-14

￿Vent Termination Cap

Outdoor – Option D-11
Indoor, Horizontal –
Option D-15
Indoor, Vertical (by others)
￿ Combustion Air
In-Line Filter Kit (TruSeal	L
only) – Option D-17	W
Air Intake Elbow –
Option D-16

Catalog No.: 6000.342B Effective: 8-15-08 Replaces: 3-1-07