Raypak 2100-4001 warranty Hydronic Heating Boilers, Commercial, Engineer, Contractor, Prepared By

Job:		Raytherm® - Type H
Engineer:		Hydronic Heating Boilers
Contractor:		Commercial
Prepared By:		Models 2100-4001 (Indoor)
Model:	Date:
EFFICIENT
82% thermal efficiency – highest of any atmospheric
boiler available today
THERMAL SHOCK PROOF
Twenty-year warranty against thermal shock damage
up to 150°F differential
Maximum operating temperature: 230°F
LIGHTWEIGHT
A floor load of 70 lbs./sq. ft. or less
HIGH RECOVERY
Cuts fuel costs substantially because the standby and
radiation losses normal to other boilers and tank-type
water heaters are eliminated
LOW WATER OPERATING TEMPERATURE		Fig. 8184
Operates with water temperature as low as 105°F
without condensing

Heat Exchanger

ƒASME Inspected and Stamped 160 PSIG

ƒNational Board Approved

ƒHeaders

Glass-lined Cast Iron – Standard

Bronze – Option A-1

ƒFinned Tubing

Copper – Standard

Cupro Nickel – Option A-3

ƒASME Steel Tube Sheet

ƒSilicone O-Rings

ƒ60 PSIG ASME Pressure Relief Valve

ƒTemperature and Pressure Gauge (Boiler)

ƒWater Connections

Left Hand – Standard

Right Hand – Option A-6

ƒFlow Configuration

Two-pass (Standard)

Single-pass (Cast Iron Only)

Controls

ƒ120V, 60Hz, 1 Ph Power Supply

ƒ120/24V Transformer

ƒ100% Pilot Shut-off/Lockout

ƒElectronic, Intermittent Ignition (IID) Pilot

ƒHigh Limit Control, Manual Reset

ƒHigh Limit Control, Auto Reset – Models 3001-4001

ƒOn/Off Switch

ƒFlow Switch

ƒEconomaster II Pump Time Delay

Gas Control Train

ƒManual Main Gas Shut-off Cock

ƒMain Gas Pressure Regulator

ƒRedundant Safety Shut-off Valve

ƒControl Valve

ƒFiring Mode

On/off (H4)

Two-stage Firing (H3)

Four-stage Firing (H9)

Motorized Modulation (H2)

B-6000 (H6)

ƒFuel

Natural Gas

Propane Gas

ƒDesign Certified ANSI Z21.13/ CSA 4.9

Construction

ƒFront Controls

ƒStainless Steel Burners

ƒPolytuf Powder Coat Finish

ƒBuilt-in Draft Diverter

ƒDraft Inducer

Motorized Draft Inducer – Option D-2

Temperature Controllers

B-7	Modulating
B-5	Modulating, Outdoor Reset
B-6	Two-stage
B-	Four-stage Digital
Y-241	Electronic Sequencer,
	1-4 Stages
Y-281	Electronic Sequencer,
	1-8 Stages

Additional Safety Controls

F-9 Low Water Cut-off Probe

I-1 High Limit Control,

Auto Reset

S-1 Low Gas Pressure Switch

S-2 High Gas Pressure Switch

Regulatory Agency Requirements

Catalog No.: 2000.26M Effective: 12-1-07 Replaces: 12-1-99