Regency Wraps U38-LP1, U38-NG1 installation manual

FPI FIREPLACE PRODUCTS INTERNATIONAL LTD. 6988 Venture St., Delta, BC Canada, V4G 1H4

WARNING:

If the information in these instructions are not followed ex-

actly, a ﬁ re or explosion may result causing property damage,

personal injury or loss of life.

FOR YOUR SAFETY

Do not store or use gasoline or other ﬂ ammable vapors and

liquids in the vicinity of this or any other appliance.

Installation and service must be performed by a qualiﬁ ed

installer, service agency or the gas supplier.

FOR YOUR SAFETY

What to do if you smell gas:

Do not try to light any appliance

Do not touch any electrical switch:

do not use any phone in your build-

ing.

Immediately call your gas supplier

from a neighbour's phone. Follow

the gas supplier's instructions.

If you cannot reach your gas sup-

plier, call the ﬁ re department.

918-530

MODELS: U38-NG1 Natural Gas U38-LP1 Propane

07/17/06

ULTIMATE U38 Freestanding Gas StoveOwners & Installation Manual

Tested by:

Installer: Please complete the details on the back cover

and leave this manual with the homeowner.

Homeowner: Please keep these instructions for future reference.

www.regency-ﬁ re.com

Contents

Main ULTIMATE U38 Freestanding Gas Stove Owners & Installation Manual Page TABLE OF CONTENTS OPERATING INSTRUCTIONS MAINTENANCE PARTS LIST WARRANTY SAFETY LABEL Copy of the Safety Label for the U38-1 Freestanding Gas Stove Model/Modele: U38-NG1 Model/Modele: U38-LP1 REQUIREMENTS MA Code - CO Detector (for the State of Massachusetts only) BEFORE YOU START IMPORTANT MESSAGE SAVE THESE GENERAL SAFETY INFORMATION INSTALLATION CHECKLIST Outside Air Through Rear of Pedestal OPTIONAL OUTSIDE AIR Outside Air Through Pedestal Bottom CLEARANCES TO COMBUSTIBLES U38-NG1 & U38-LP1 REFERENCE DIMENSIONS U38-NG1 & U38-LP1 Clearances Page S.I.T. Valve Description GAS PIPE PRESSURE TESTING GAS CONNECTION System Data: HIGH ELEVATION - U38-NG1 System Data U38-1 with 40,000 BTU System Data U38-1 Converted to 30,000 Btu CONVERSION KIT# 731-969 FOR NG TO LP THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !! Fig.3 Fig.4 Each Kit contains one LPG Conversion Kit and one DC Sparker Kit. Fig.6 WARNING! Do not over tighten the screw. Recommended to grip the wrench by the short side. Fig.5 LPG Configuration Red o-ring visible Page LOG SET The gas log kit contains the following: CONVERSION TO LOWER BTU RATING THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !! F)02-47 G)02-48 D)02-46 TEST FOR FLUE SPILLAGE LOUVER FRONT DOOR (packaged separately) OPTIONAL REMOTE CONTROL FINAL CHECK CAUTION OPTIONAL WALL THERMOSTAT Page Page SHUTDOWN FIRST FIRE OPERATING INSTRUCTIONS LIGHTING DO NOT ATTEMPT TO CLEAN THE GLASS WHILE IT IS STILL HOT! COPY OF THE LIGHTING PLATE INSTRUCTIONS DO NOT REMOVE THIS INSTRUCTION PLATE FOR YOUR SAFETY READ BEFORE LIGHTING FOR UNITS NOT EQUIPPED WITH ELECTRIC SPARK: TO TURN OFF GAS APPLIANCE NORMAL OPERATING SOUNDS OF GAS APPLIANCES AERATION ADJUSTMENT PILOT ADJUSTMENT MAINTENANCE MAINTENANCE LOG REPLACEMENT DOOR AND GLASS GASKET GOLD-PLATED DOORS MAINTENANCE FAN MAINTENANCE Replacing U38-1 Fan: To Remove U38-1 Fan: REMOVING VALVE Page Page U38-1 DOOR ASSEMBLIES PARTS LIST Page Page Page WARRANTY