Contents
Main
ULTIMATE U38 Freestanding Gas Stove
Owners & Installation Manual
Page
TABLE OF CONTENTS
OPERATING INSTRUCTIONS
MAINTENANCE
PARTS LIST
WARRANTY
SAFETY LABEL
Copy of the Safety Label for the U38-1 Freestanding Gas Stove
Model/Modele: U38-NG1 Model/Modele: U38-LP1
REQUIREMENTS
MA Code - CO Detector
(for the State of Massachusetts only)
BEFORE YOU START
IMPORTANT MESSAGE SAVE THESE
GENERAL SAFETY INFORMATION
INSTALLATION CHECKLIST
Outside Air Through Rear of Pedestal
OPTIONAL OUTSIDE AIR
Outside Air Through Pedestal Bottom
CLEARANCES TO COMBUSTIBLES
U38-NG1 & U38-LP1 REFERENCE DIMENSIONS
U38-NG1 & U38-LP1 Clearances
Page
S.I.T. Valve Description
GAS PIPE PRESSURE TESTING
GAS CONNECTION
System Data: HIGH ELEVATION - U38-NG1
System Data U38-1 with 40,000 BTU
System Data U38-1 Converted to 30,000 Btu
CONVERSION KIT# 731-969 FOR NG TO LP
THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !!
Fig.3
Fig.4
Each Kit contains one LPG Conversion Kit and one DC Sparker Kit.
Fig.6
WARNING! Do not over tighten the screw. Recommended to grip the wrench by the short side.
Fig.5
LPG Configuration Red o-ring visible
Page
LOG SET
The gas log kit contains the following:
CONVERSION TO LOWER BTU RATING
THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !!
F)02-47
G)02-48 D)02-46
TEST FOR FLUE SPILLAGE
LOUVER
FRONT DOOR
(packaged separately)
OPTIONAL REMOTE CONTROL
FINAL CHECK
CAUTION
OPTIONAL WALL THERMOSTAT
Page
Page
SHUTDOWN
FIRST FIRE
OPERATING INSTRUCTIONS
LIGHTING
DO NOT ATTEMPT TO CLEAN THE GLASS WHILE IT IS STILL HOT!
COPY OF THE LIGHTING PLATE INSTRUCTIONS
DO NOT REMOVE THIS INSTRUCTION PLATE
FOR YOUR SAFETY READ BEFORE LIGHTING
FOR UNITS NOT EQUIPPED WITH ELECTRIC SPARK:
TO TURN OFF GAS APPLIANCE
NORMAL OPERATING SOUNDS OF GAS APPLIANCES
AERATION ADJUSTMENT
PILOT ADJUSTMENT
MAINTENANCE
MAINTENANCE
LOG REPLACEMENT
DOOR AND GLASS GASKET
GOLD-PLATED DOORS
MAINTENANCE
FAN MAINTENANCE
Replacing U38-1 Fan:
To Remove U38-1 Fan:
REMOVING VALVE
Page
Page
U38-1 DOOR ASSEMBLIES
PARTS LIST
Page
Page
Page
WARRANTY